Ultrasonic vibration-induced thinning of intermetallic compound layers in friction stir welding of dissimilar Al/Mg alloys
Authors:
- 1 November 2022
- journal article
- research article
- Published by SAGE Publications in Science and Technology of Welding and Joining
- Vol. 27 (8) , 621-628
Abstract
Frictions stir welding (FSW) and ultrasonic vibration enhanced FSW (UVeFSW) of dissimilar Al/Mg alloys were conducted, and the intermetallic compounds (IMCs) layers formed at Al/Mg interface in welds were characterised by TEM. It was found that the IMCs thickness was significantly reduced in UVeFSW, and the IMCs were generated by solid-state atomic diffusion in butt joints under the used welding conditions since the measured temperature at the tool/workpiece interface was far below the eutectic points. The EBSD characterisation showed that ultrasonic vibration improved the degree of grain recrystallization on both sides of the IMCs layers and promoted the consumption of dislocations, which resulted in a reduced diffusion rate of atoms. Therefore, the growth of IMC layer was suppressed in UVeFSW.Keywords
Funding Information
- National Natural Science Foundation of China (52035005)
This publication has 26 references indexed in Scilit:
- State of the art about dissimilar metal friction stir weldingScience and Technology of Welding and Joining, 2017
- A review of dynamic recrystallization phenomena in metallic materialsMaterials & Design, 2016
- Evaluation of local strain distribution in ultrasonic enhanced Al 6061-T6 friction stir weld nugget by EBSD analysisMaterials & Design, 2016
- Microstructure evolution during friction-stir welding of AZ31 magnesium alloyActa Materialia, 2015
- Modeling of Intermetallic Compounds Growth Between Dissimilar MetalsMetallurgical and Materials Transactions A, 2015
- Realization of Al/Mg-Hybrid-Joints by Ultrasound Supported Friction Stir WeldingMaterials Science Forum, 2014
- New insight on acoustoplasticity – Ultrasonic irradiation enhances subgrain formation during deformationInternational Journal of Plasticity, 2011
- Orientation gradients and geometrically necessary dislocations in ultrafine grained dual-phase steels studied by 2D and 3D EBSDMaterials Science and Engineering: A, 2010
- Effect of Intermetallic Compound Layer on Tensile Strength of Dissimilar Friction-Stir Weld of a High Strength Mg Alloy and Al AlloyMATERIALS TRANSACTIONS, 2009
- Microstructural investigation of friction stir welded 7050-T651 aluminiumActa Materialia, 2003