Plasma-sprayed alumina coating on Inconel 600 for fast reactor neutron detector application
- 1 October 2018
- journal article
- research article
- Published by SAGE Publications in Surface Engineering
- Vol. 34 (10) , 721-727
Abstract
Alumina coating, with high electrical resistivity, has been proposed over Inconel 600 rings for application in fission chamber neutron detectors, operating at 923 K in fast breeder reactor. For improving the thermal cycling life and adhesion strength of alumina coating, selection of the suitable coating technique and bond coat, with appropriate spray parameters was pursued. In the present study, Ni–50%Cr bond coat was deposited over Inconel 600 by the high velocity oxygen fuel technique, while the top alumina coat was deposited using air plasma spray process. A dense coating with minimum porosity and a stable insulation resistance (600 V DC) of ∼1011 ohm at room temperature and ∼108 ohm at 923 K was achieved. Thermal cycling studies on coated samples and rings showed good thermal cycle life tested up to 100 cycles. The coating exhibited good bond strength and only marginal decrease in bond strength was observed with increase in thermal cycling.Keywords
This publication has 13 references indexed in Scilit:
- Damage mechanisms and lifetime behavior of plasma sprayed thermal barrier coating systems for gas turbines—Part I: ExperimentsSurface and Coatings Technology, 2008
- Comparison of thermal cycling behavior of plasma-sprayed nanostructured and traditional thermal barrier coatingsMaterials Science and Engineering: A, 2007
- Thermal shock resistance and adhesion strength of plasma-sprayed alumina coating on cast ironThin Solid Films, 2006
- Design and Fabrication of ZrO2/Stainless Steel Thermal Barrier Coating FGMMaterials Science Forum, 2005
- Effect of thermal cycling on the adhesive strength of Ni–Cr coatingsSurface and Coatings Technology, 2005
- Ceramic materials for thermal barrier coatingsJournal of the European Ceramic Society, 2004
- Influence of oxide mixtures on mechanical properties of plasma sprayed functionally graded coatingThin Solid Films, 2000
- Thermal Cycling Behavior of Plasma-Sprayed Thermal Barrier Coatings with Various MCrAIX Bond CoatsJournal of Thermal Spray Technology, 2000
- Microstructure formation in plasma-sprayed functionally graded NiCoCrAlY/yttria-stabilized zirconia coatingsSurface and Coatings Technology, 1999
- Ceramics and ceramic-to-metal sealingVacuum, 1964