Rafał Nadulski

Gradual climate warming is favoring viticulture in Poland. At the same time, there is a lack of information about the suitability of grape varieties grown in Poland for processing. The primary aim of the study was to determine the effect of pre-treatment on the pressing yield of grape juice and its qualitative assessment. The study applied pre-treatment of raw material, involving either enzymatic liquefaction of the pulp in the first case or freezing and thawing of the pulp prior to pressing in the second case. There was considerable variation among the grape varieties studied in terms of the characteristics under analysis. The varietal characteristics had a significant effect on the pressing yield and the quality of the juice obtained. Pre-treatment had different effects on the pressing yield of the individual grape varieties and the quality of the obtained juices. The research carried out may improve the efficiency and quality of agricultural production with the rational use of locally grown grape hybrids.

The current study aimed to assess the quality of selected liquid food products made from apple juice and available on the domestic market. The study determined the extract content, pH and density of twenty products, i.e., juices, nectars, soft drinks and smoothies from different producers. The study shows that the apple juice-based liquid products tested differ in terms of quality. The analyses also show that there is a greater variation in the apple juice-based liquid products tested in terms of extract content, to a lesser extent in terms of acidity, whereas in terms of density, it is small but statistically significant. The highest extract content, density and pH values were noted for the smoothies and apple juices, whereas the lowest values were noted for soft fruit drinks and nectars.

This study investigated the effects of particle size and ultrasonic parameters on the yields of bioactive compounds extracted from the leaves and inflorescences of hemp. The total flavonoid and anthocyanin contents were determined using the spectrophotometric method. The response surface methodology (RMS) was employed to optimize the yield of bioactive substances. On the basis of the developed model, the highest flavonoid yield was obtained under the following extraction conditions: particle size, 0.59 mm; extraction time, 10.71 min; ultrasound intensity, 7.13 W∙cm⁻²; extraction yield, 9.28 mg QE∙g⁻¹; determination coefficient, R² = 0.97. The optimal conditions for extracting anthocyanins were as follows: particle size, 0.25 mm; extraction time, 15 min; ultrasound intensity, 8.60 W∙cm⁻²; extraction efficiency, 20.27 mg Cy-GE∙100 g⁻¹; determination coefficient, R² = 0.87. This study helped confirm the importance of pulsed ultrasound-assisted extraction in obtaining bioactive compounds from hemp.

The aim of this study was to develop a concept, within the framework of sustainable agriculture, for utilizing apple pomace as a valuable raw material in food production. The proposal includes a description of the production technology of four food products together with the characteristics of their chemical composition, wholesome compounds, and physical properties. These new products were developed on the basis of apple pomace and wheat bran. In the developed technology, heat treatment in a convection oven, treatment with infrared radiation, and two types of barothermic treatments, i.e., extrusion and granulation, were implemented as the principal methods. All of the proposed technologies allow for the use of pomace for the production of food products to be made directly in the home plant and are relatively easy to implement in small processing facilities. It was found that the product consisting of fragmented apple pomace (mass fraction: 75%) and wheat bran (mass fraction: 25%), obtained using infrared radiation treatment, had the greatest value in terms of wholesome characteristics among the products obtained. This product had high contents of fiber and simple sugars, the highest content of polyphenols among the obtained products, and the ability to scavenge free radicals. It was also the only one with partially preserved vitamin C. The proposed method for processing pomace for food is in line with the sustainable agriculture movement.

Grain viability is of key importance in the production of malt. This paper presents the results of research on the influence of vacuum impregnation of grains of various cereals on theirservice life. One malting barley cultivar, two wheat cultivars, and a rye cultivar mix were tested. The grain was subjected to wet vacuum impregnation and wet vacuum impregnation carried out cyclically under the pressure of 5 kPa. Then, samples of the impregnated grain were sown and its germination capacity was tested every 24 h to 120 h. The control sample was grain soaked under atmospheric pressure. Vacuum impregnation did not cause any significant changes in the germination capacity of the examined cereal varieties. The vacuum-impregnated grain displayed a higher initial water content and germinated faster. It was found that the impregnation did not disturb the internal structure of the grain, indicated by the fact that the most delicate part of the grain, i.e., the embryo, retained its vital functions in every examined case.

The paper presents the comparison of quality of six different commercial apple juices produced in Poland. The apple juices came from two different Polish companies. From each manufacturer three various juices were selected: two cloudy and clarified one produced as a mixture of different apple varieties. The following properties were evaluated: density, soluble solid content, viscosity, total phenolic contents, phenolic acid, and antiradical activity. The obtained results showed that three from fourth cloudy juices (M1Sz, M1A and M2A) differed from clarified juices. The highest differences were noticed for total phenolic contents, phenolic acids, antiradical activity and viscosity. The values of these properties ranged between 60.72–103.6 mg GAE·100⁻¹ mL⁻¹ for phenolic contents, 78.3–90.9% for antiradical activity and 2.68–5.79 mPa·s for viscosity. The remaining cloudy juice (M2Sz) was more similar to the clarified ones. The strong correlation between total phenolic content and antiradical activity of apple juices was found. The high correlation coefficient obtained between these features indicates that both producers do not apply excessive amounts of vitamin C during the production of cloudy apple juices. There was also a strong interrelation between the density of juice and solid soluble content. However, no correlation was found between the solid soluble content and the viscosity of the tested juices.

The aim of this study is to indicate the influence of pretreatment, consisting of grinding vegetables and then freezing and thawing the raw material before pressing on the process efficiency and quality of obtained juice. The subject of the research was celeriac root (Apium graveolens L) of the Edward variety. Juice pressing was carried out in a laboratory basket press. The pressing yield and specific energy were values characterizing the pressing process, while pH and the extracted content in the juice were used to assess the juice quality. The experiment was performed according to three procedures. In each of them, the ground celeriac root (pulp or chips) was initially pretreated through freezing and thawing and then pressed twice. Among the examined methods of obtaining juice, the most beneficial method was pressing juice from the pulp, then freezing and thawing the pomace obtained in the first cycle, and finally, pressing the pomace. It is an energy-optimal method and guarantees a high pressing yield as well as obtaining juice with a higher soluble solid content than during the process of pressing chips.

The paper presents the possibility of applying a twin-screw press for juice extraction from apples with different textural properties. The research was carried out with six different varieties; namely, Granny Smith, Modi, Ligol, Lobo, Boscop and Szampion. During the experiment, the following properties were measured: texture properties, pressing yield and polyphenolic content; and ascorbic acid content and antioxidant activity both in raw apples and apple juice. Based on the analysis, three hardness levels of apples can be distinguished, impacting the course of juice pressing in a twin-screw press (low hardness below 30 N, medium hardness 30–50 N and high hardness 50 N). The study showed that only high hardness apples are suitable for pressing on a twin-screw press. The mechanism by which texture properties influence the juice pressing process in the studied press was explained. It was further demonstrated that the hardness of apples has a positive impact on the degree of extraction of polyphenols and ascorbic acid into apple juice. This is caused by the different fracture patterns of tissues with different mechanical properties. High hardness apples (Granny Smith and Modi) were characterized by a considerably greater degree of bioactive substance extraction into juice than medium hardness apples.

This paper presents the results of a study on the influence of juice extraction and thermosonication methods on the content of microorganisms in juices stored under refrigeration and in ambient temperature. It was determined that the type of extraction device used influenced the content of microorganisms in juice. The lowest total content of mesophilic microorganisms was obtained in juice extracted on a piston press, and the highest was obtained using a centrifuge. The additional purpose was to evaluate the influence of ultrasonic treatment on selected parameters of apple juice quality: cloud value, antioxidant activity, total phenolic content, flavonoid content, and anthocyanin content. The ultrasound treatment of juice from the piston press was conducted at two levels of radiated sonic power so as to obtain sublethal and lethal temperatures of the juice. It was demonstrated that only ultrasound treatment within the range of lethal temperatures was sufficient to deactivate microorganisms. It was determined that thermosonication did not influence the deterioration of chemical properties of juices, with the exception of decreased anthocyanin content. The described method enables prolongation of the shelf life of fresh apple juice under refrigeration to 168 hours (7 days).