Bin Shang

In-depth exploration of filtration behavior and fouling characteristics of polymeric ultrafiltration (UF) membranes can provide guidance for the selection of materials and the control of membrane fouling during the purification of digestate. In this study, four types of polymeric membranes, (polyethersulfone (PES), polysulfone (PS), polyvinylidene fluoride (PVDF), and polyacrylonitrile (PAN)), were employed to filter digestate from swine manure. The results showed that the viscosity of the digestate dropped from 45.0 ± 11.3 mPa·s to 18.0 ± 9.8 mPa·s, with an increase in temperature from 30.0 °C to 45.0 °C. The four membrane fluxes all increased by more than 30%, with the cross flow velocity increasing from 1.0 m s⁻¹ to 2.0 m s⁻¹. During the batch experiments, the flux maintenance abilities of the membranes were in the order: PAN > PS > PVDF > PES. There were no significant differences in the effects of membrane materials on the removal of COD, TN, and TP (p < 0.05). For UV₂₅₄ removal efficiency, PS showed the highest efficiency (68.6%), while PVDF showed the lowest efficiency (63.4%). The major fouling type was irreversible hydraulic fouling, and the main elements of scaling were C, O, S, and Ca. Pseudomonadales were the dominant bacteria in the PS (26.2%) and in the PVDF (51.4%) fouling layers, while Bacteroidales were the dominant bacteria in the PES (26.8%) and in the PAN (14.7%) fouling layers. The flux recovery rates (FRRs) of the cleaning methods can be arranged as follows: NaClO > NaOH > Citric acid ≈ Tap water. After NaClO cleaning, the PVDF membrance showed the highest FRR (73.1%), and the PAN membrane showed the lowest FRR (30.1%).

Soilless cultivation of vegetables is widely used in production. It is also well accepted that digested slurry is frequently applied as a fertilizer in agricultural production. However, the effect of digested pig slurry on yield and quality of tomato soilless cultivation, as well as the yield and quality influenced by plant carbohydrate metabolism, remain unexplored. Here, the dual inputs of fertilizers (digested pig slurry (D) and mineral fertilizer (M)) and soilless substrates (peat substrate (P) and cinder substrate(C)) consisted of four treatments. The dry biomass and fruit yields, photosynthetic parameters, carbohydrate contents and metabolism enzymes in leaves and fruits were recorded during the experimental period. The highest fruit yields were obtained in DP and MP treatments. Although DP treatment significantly increased the fresh weight of single fruits by 18.0% compared to MP treatment, it reduced the number of ripe fruits. The photosynthetic efficiency and carbohydrate contents (sucrose, glucose and fructose) in leaves were generally higher in DP treatment compared to other treatments, as well as the activities of sucrose phosphate synthase and AGPase in leaves. The soluble sugar contents of fruits in DP and DC treatments were enhanced by 12.3% and 37.0%, respectively, compared to MP and MC treatments. Moreover, the current results showed that DP treatment significantly increased the activity of acid invertase in fruit by 36.3%, 31.3%, and 42.2%, respectively, compared to MP, DC, and MC treatments, and decreased the activity of AGPase by 24.2%, 16.0%, and 36.4%, respectively. The current results have demonstrated that DP treatment had better yield and quality, owing to digested pig slurry increasing the photosynthetic efficiency and source strength, and regulated the activities of carbohydrate metabolism enzymes.

Degradable hemostatic materials have unique advantages in reducing the amount of bleeding, shortening the surgical operation time, and improving patient prognosis. However, none of the current hemostatic materials are ideal and have disadvantages. Therefore, a novel biodegradable cellulose-based composite hemostatic material was prepared by crosslinking sodium carboxymethyl cellulose (CCNa) and hydroxyethyl cellulose (HEC), following an improved vacuum freeze-drying method. The resulting cellulose composite material was neutral in pH and spongy with a density of 0.042 g/cm³, a porosity of 77.68%, and an average pore size of 13.45 μm. The composite’s compressive and tensile strengths were 0.1 MPa and 15.2 MPa, respectively. Under in vitro conditions, the composites were degraded gradually through petite molecule stripping and dissolution, reaching 96.8% after 14 days and 100% degradation rate at 21 days. When implanted into rats, the degradation rate of the composite was slightly faster, reaching 99.7% in 14 days and 100% in 21 days. Histology showed a stable inflammatory response and no evidence of cell degeneration, necrosis, or abnormal hyperplasia in the tissues around the embedded material, indicating good biocompatibility. In the hemorrhagic liver model, the time to hemostasis and the total blood loss in the cellulose composite group was significantly lower than in the medical gauze group and the blank control group ( ). These data indicate that the novel cellulose composite is a promising implantable hemostatic material in clinical settings.

Emissions of odorous compounds, such as ammonia (NH₃), from composting have negative agronomic and environmental impacts. A biofilter is widely used for NH₃ removal, with one of its potential detrimental by-products being nitrous oxide (N₂O), which is a higher warming potential greenhouse gas (GHG). The aim of the study was to evaluate the effect of empty bed retention time (EBRT) on GHG emissions from biofilters for removing NH₃ from composting. Composting experimental trials lasted 6 weeks, and composting materials were mixtures of dead pigs and manure. Three groups of biofilters with 1.2 m-height, 0.3 m-inner diameter, and 1.0 m media depth were conducted with EBRT of 30, 60, and 100s, respectively. Each treatment was performed in triplicate, and the gas was monitored using the dynamic emission vessel method. The Spearman’s correlation analysis showed a significantly positive correlation between inlet concentrations (ICs) of NH₃ and increased N₂O concentrations: ρ = 0.707, 0.762, and 0.607 with p ≤ 0.0001 for biofilters with EBRT of 30, 60, and 100s, respectively. The fraction of NH₃-N denitrified into N₂O-N in biofilters with EBRT of 60 and 100s was higher than that with EBRT of 30s. The total global warming potential (GWP) increased by 126%, 162%, and 144% for biofilters with EBRT of 30, 60, and 100s, respectively. These results indicated that biofilters with longer EBRT will lead to higher GWP production. Future research on odorous mitigation for composting with biofilters should focus more on greenhouse gas emissions.

Ultrafiltration (UF) can effectively remove large particles, suspended solids, and colloidal substances from anaerobic digestate. However, membrane fouling is a technical challenge in the purification of the digestate by UF. In this study, polyethersulfone (PES) membranes with four pore sizes (50.0, 20.0, 10.0 and 5.0 kDa) were employed to filter anaerobic digestate from swine manure. The effects of temperature, transmembrane pressure (TMP), and cross-flow velocity (CFV) on flux were investigated. The purification effects and fouling characteristics of the four membranes were analyzed. The results revealed that the increase of temperature and CFV can effectively promote UF separation efficiency, but as the TMP exceeded 3.0 bar, the flux increase rates of the four membranes were almost zero. The larger membrane pore size caused the faster flux increase with the increase in pressure. During the batch experiment, the 20.0 kDa membrane showed the lowest flux maintenance ability, while the 5.0 kDa showed the highest ability due to the smaller pore size. All four membranes can effectively remove tetracyclines residues. Elements C, O, and S were the major membrane foulant elements. The dominant bacteria orders of membrane fouling were Pseudomonadales, Xanthomonadales and Burkholderiales. Compared with tap water and citric acid, the membrane cleaning by NaOH and NaClO showed higher flux recovery rates. The 50.0 kDa membrane achieved the best cleaning effects under all cleaning methods.

Odor emission is one of the most common problems associated with dead animals composting. Biofiltration treatment for eliminating exhaust odors formed during dead pigs and manure composting has been studied. The composting and biofiltration process consisted of two series of tests. Composting experimental trials lasted 6 weeks, and composting was performed using six pilot-scale reactor vessels. A total of 37 kinds of volatile organic compounds (VOCs) present in the air were identified, and temporal variations were determined during the 42 days of composting. Dimethyl sulfide (DMS), dimethyl disulfide (DMDS), dimethyl trisulfide (DMTS), and trimethylamine (TMA) were identified as the main odors VOCs component according to odor active values (OAVs). Nine biofilter vessels containing mature compost were used in studying the effect of different (30, 60, and 100 s) empty bed retention times (EBRT) on the simultaneous removal efficiencies (REs) of NH₃, DMS, DMDS, DMTS, and TMA. Results indicated that the inlet concentration of NH₃ applied was 12–447 mg m⁻³, and the average removal efficiencies were 85.4%, 88.7%, and 89.0% for EBRTs of 30, 60, and 100 s, respectively. The average REs of DMS, DMDS, DMTS, and TMA were 79.2%–95.4%, 81.9%–94.0%, 76.7%–99.1%, and 92.9%–100%, respectively, and their maximum elimination capacity (ECs) were 220, 1301, 296, and 603 mg m⁻³ h⁻¹, respectively. The optimal EBRT for the stimulation removal of NH₃, DMS, DMDS, DMTS, and TMA was 60 s. Implications: Dimethyl sulfide (DMS), dimethyl disulfide (DMDS), dimethyl trisulfide (DMTS), and trimethylamine (TMA) were identified as the main odors VOCs component during dead pigs and manure composting. Biofilter with mature as media can be used to stimulation remove NH₃, DMS, DMDS, DMTS, and TMA, the optimal empty bed retention times EBRT was 60 s.