Rosa Escudero

This study explored the effects of replacing pork meat with 5, 10 and 15% cricket ( Acheta domesticus ) flour in Spanish dry-fermented sausages (salchichón). Four formulations (control, AD5, AD10, AD15) were assessed for their nutritional composition, fatty acid profile, volatile compounds, physicochemical properties (pH and water activity), technological parameters (instrumental colour and texture), typical microbiota and sensory attributes. Results showed that increasing cricket flour replacement in the sausages lowered the fat content and elevated moisture, protein and fibre contents ( ) without affecting microbial counts (lactic acid bacteria and Gram-positive catalase-positive cocci), pH and water activity. Cricket flour improved the volatile profile, particularly enhancing carbohydrate fermentation and amino acid degradation volatiles, while significantly reducing lipid oxidation-derived compounds ( ), suggesting potential antioxidant properties. Slight decreases and increases were observed in monounsaturated and polyunsaturated fatty acids, respectively, especially at the highest substitution levels ( ). Instrumental colour analysis indicated a decrease in lightness and redness in sausages with higher cricket flour levels, resulting in a darker and brownish colour ( ). Texture analysis revealed higher hardness and chewiness with increased cricket flour, especially in the AD15 formulation ( ). Sensory evaluations showed that a 5% meat substitution by cricket flour yielded a product acceptability similar to the control with no differences in the evaluated attributes, while higher levels were less preferred in terms of colour, texture, taste, acceptability and overall preference ( ). These findings indicate that cricket flour could be used as a novel ingredient for dry-fermented sausages, especially at a 5% substitution level, potentially offering a promising balance between sustainability, innovation, product quality and consumer acceptance. Higher replacement levels provide a foundation for refining processing methods or incorporating functional additives to enhance palatability.

The increasing demand for sustainable and nutritionally rich protein sources has led to a growing interest in edible insects as a viable alternative to traditional meat. This study evaluates the potential of mealworm (Tenebrio molitor) flour as a partial meat replacer in the formulation of dry fermented sausages (salchichón). Four formulations were prepared, replacing 0%, 5%, 10%, and 15% of pork meat with mealworm flour, and their microbiological, physicochemical, rheological, technological, and sensory properties were analyzed. Results showed that the incorporation of mealworm flour did not compromise the growth of lactic acid bacteria or Gram-positive catalase-positive cocci, both essential for fermentation and curing. The inclusion of mealworm flour significantly increased the protein, fiber, and polyunsaturated fatty acid (PUFA) content of the sausages, improving their nutritional profile. Notably, despite the higher PUFA content, lipid oxidation was reduced, as evidenced by lower concentrations of oxidation-derived volatile compounds. Significant changes were also observed in color, particularly at higher replacement levels, which resulted in a noticeable darkening of the sausages. Sensory evaluation indicated that replacing up to 5% of pork meat maintained product acceptability, whereas higher levels caused significant changes. The partial replacement of pork by mealworm flour shows interesting possibilities to produce more sustainable and functional dry fermented meats.

Fifty-eight litters (16 from primiparous gilts and 42 from multiparous sows) were used, with a total number of 750 piglets involved in the study. Birth weight was stratified into three groups: low (1.62 kg; HBW). A creep feeding diet was offered to piglets in a creep feeder in 29 litters from day 7 until their weaning. Piglet mortality was recorded daily. Traceability was ensured up to the point of carcass splitting and subsequent meat analysis. Each carcass was eviscerated and weighed individually. Sixty-nine piglets were selected for the microbiome analysis (35 from the control group and 34 from the creep feeding group). Feces samples from the rectum were obtained at three time points (three days prior weaning, a week after weaning, and before the slaughtering of the pigs). Mortality during lactation was influenced by birth weight, with LBW piglets exhibiting a six-fold higher mortality rate than HBW. Creep feeding did not impact piglet mortality. Heavier piglets demonstrated greater weight gain when subjected to creep feeding, while the growth potential of lighter piglets was reduced. Variation in creep feeding consumption based on birth weight also affected microbiome composition, with high-birth-weight piglets displaying higher alpha diversity than low- and normal-birth-weight piglets seven days after lactation. Alpha diversity is indicative of gut health, with higher values suggesting greater stability and adaptability to different feed sources. In conclusion, the immediate impacts of creep feeding appear to be most prominent during lactation and potentially early postweaning. These short-term effects are modulated by birth weight, with HBW piglets demonstrating the greatest benefits from the implementation of creep-feeding practices.

Heat stress is a significant environmental problem that has a detrimental impact on animal welfare and production efficiency in swine farms. The current study was conducted to assess the effect of low-intensity showers, provided during critical high-temperature hours daily, on body external temperature, feeding pattern, and carcass and meat quality characteristics in fattening pigs. A total of 400 animals (200 barrows and 200 gilts) were randomly allotted in 40 pens. A shower nozzle was installed over 20 pens (half barrows and half gilts) where pigs received a low-intensity shower for 2 min in 30 min intervals from 12 to 19 h (SHO group). Another group without showers was also considered (CON). Feeder occupancy measurement, thermographic measures, and carcass and meat quality parameters were studied. In the periods with higher environmental temperatures, SHO animals showed an increase in the feeder occupancy rate compared to the CON group. A decrease in temperature was observed after the shower, regardless of the anatomical location (p < 0.005). The treatment with showers led to higher values than in the CON group of 4.72%, 3.87%, 11.8%, and 15.1% for hot carcass weight, lean meat yield, and fat thickness in Longissimus Dorsi (LD) and Gluteus Medius muscles, respectively (p < 0.01). Pork from CON showed a 14.9% higher value of drip loss, and 18.9% higher malondialdehyde concentration than SHO (p < 0.01); meanwhile, intramuscular fat content was 22.8% higher in SHO than in CON (p < 0.01). On the other hand, the CON group exhibited higher L* (2.13%) and lower a* and b* values (15.8% and 8.97%) compared to the SHO group. However, the pH_20h of the CON group was significantly lower than that of the SHO group (p < 0.001), indicating a softer pH decrease. Related to fatty acids in subcutaneous outer and inner layers and intramuscular fat, the CON group showed higher ΣSFA and lower ΣMUFA and Δ₉-desaturase indexes than SHO (p < 0.05). In conclusion, the amelioration of heat stress through showers at critical times should be considered an interesting tool that improves both carcass and meat quality, as well as animal welfare.

Forty-eight litters were used, with a total number of 645 piglets involved in the study. The split-suckling technique was applied to half of the litters at the end of farrowing by removing the heaviest piglets over three periods of 1 h. The piglets were individually weighed at 0, 1 d, and at weaning. Piglet losses were recorded daily. Traceability was maintained until the carcass splitting and meat analysis took place. Carcasses were eviscerated and weighed individually. Total mortality at weaning was affected by body weight, where the low-body-weight piglets showed a mortality rate almost four times higher than that of the normal-weight piglets. Mortality was highest in the first days of life, especially in the low-body-weight piglets. At weaning, split-suckling treatment caused a slight increase in mortality compared to the control group piglets (25% vs. 17.1%). Split-suckling had a positive effect on weight gain during the first 24 h of life (p = 0.014), and there was an interaction between treatment and parity (p = 0.007), with split-suckling being more effective in the primiparous sows compared to the multiparous sows. The piglets from litters receiving the split-suckling treatment had a lower average daily gain during the lactation period (p < 0.001) than the piglets from the control group. Weight gain during the first 24 h of life of the piglets subjected to split-suckling was higher than those of the control group. A lower IgG and α-tocopherol in plasma in the heavier piglets subjected to split-suckling treatment was observed in comparison to their respective control. The piglets from litters receiving the treatment showed a lower average daily gain during the lactation period (p < 0.001) than the piglets from the control group. No difference in slaughter weight was observed according to treatment. The pigs which received split-suckling treatment showed lower subcutaneous fat thickness (p < 0.0013) and higher lean meat yield (p < 0.0027), this effect being more marked in pigs from primiparous sows. Intramuscular fat concentration was higher in the Longissimus Dorsi muscle of the low-body-weight piglets. In the pigs that received split-suckling treatment, a higher concentration of C18:3n-3 (p = 0.036) and a tendency towards a higher concentration of C18:2n-6 (p = 0.107) and unsaturation index (p = 0.113) was observed in intramuscular fatty acids at slaughter, together with a lower concentration of C16:0 (p = 0.053) and SFA (p = 0.064). In conclusion, long-term response to split-suckling, particularly in low-birth-weight piglets, suggests an alteration in adiposity and metabolic regulation in these piglets that receive high levels of colostrum.

The hypothesis of this experiment was that a liquid rich in hydroxytyrosol (HT) obtained from “alperujo”, an olive oil by-product, could replace part of the added vitamin E (VE) as an antioxidant in poultry diets. There were five diets that differed exclusively in the substitution of supplemental VE (0 to 40 mg/kg, with differences of 10 mg/kg) by HT (30 to 0 mg/kg, with differences of 7.5 mg/kg). The basal diet was based on corn and soybean meal and provided 10 mg VE/kg. From 0 to 39 d of age, the growth performance of the birds was not affected by diet. The birds were slaughtered at 39 d of age to evaluate the quality of the breast, and malonaldehyde concentration, pH, color, and drip loss were measured. In terms of meat lipid oxidation, the combination of 22.5 mg HT/kg and 10 mg of added VE/kg equalized to a diet supplemented with 40 mg VE/kg. Meat color improved in broilers fed 7.5 mg HT/kg and 30 mg VE/kg. It is concluded that once the nutritional requirements of the birds in VE are satisfied, the dietary supplementation with the olive oil by-product rich in HT can be used as a strategy to spare VE in broiler diets.

An adequate intestinal environment before weaning may contribute to diarrhea predisposition and piglet development. This study evaluates how the dietary supplementation of vitamin E (VE) (100 mg/kg), hydroxytyrosol (HXT) (1.5 mg/kg) or the combined administration (VE + HXT) given to Iberian sows from gestation affects the piglet’s faecal characteristics, short chain fatty acids (SCFAs), fatty acid profile or intestinal morphology as indicators of gut health; and quantify the contribution of the oxidative status and colostrum/milk composition to the piglet’s SCFAs content and intestinal health. Dietary VE increased isobutyric acid (iC4), butyric acid (C4), isovaleric acid (iC5), and ∑SCFAs, whereas HXT increased iC4 and tended to decrease ∑SCFAs of faeces. Piglets from HXT-supplemented sows also tended to have higher faecal C20:4n-6/C20:2 ratio C22:6 proportion and showed lower occludin gene expression in the duodenum. The combination of both antioxidants had a positive effect on iC4 and iC5 levels. Correlation analyses and regression equations indicate that faecal SCFAs were related to oxidative status (mainly plasma VE) and colostrum and milk composition (mainly C20:2, C20:3, C20:4 n-6). This study would confirm the superiority of VE over HXT supplementation to improve intestinal homeostasis, gut health, and, consequently piglet growth.

Different feeding strategies are being applied to sows in order to obtain homogeneous piglets’ weights and improved health status. This study evaluated how the dietary supplementation of vitamin E (VE) (100 mg/kg), hydroxytyrosol (HXT) (1.5 mg/kg) or the combined administration (VE + HXT) given to Iberian sows from day 85 of gestation affected the growth pattern of the piglets and their oxidative status; and quantified what these effects were due to. Dietary VE and HXT improved the oxidative status of sows and piglets. Both VE and HXT modified the growth pattern at birth and performances of the piglets in a different way according to the growing period. Piglets’ performances were positively correlated with plasma VE and negatively with plasma malondialdehyde (MDA) of the sow. However, the highest variation in growth patterns was explained by the colostrum composition. Significant linear equations were observed between piglets’ performances and colostrum saturated (SAT), n-7 monounsaturated fatty acids (C16:1n-7 and C18:1n-7) and different desaturases indices. This study would confirm that VE supplementation to the sow diet could be more adequate than HXT for the improved development during the first weeks of a piglet’s life. The combined administration of both antioxidants would not produce additional positive effects compared to the individual supplementation.

Modifying the composition of a sow’s milk could be a strategy to improve the intestinal health and growth of her piglet during the first weeks of life. This study evaluated how dietary supplementation of vitamin E (VE), hydroxytyrosol (HXT) or VE+HXT given to Iberian sows from late gestation affected the colostrum and milk composition, lipid stability and their relationship with the piglet’s oxidative status. Colostrum from VE-supplemented sows had greater C18:1n−7 than non-supplemented sows, whereas HXT increased polyunsaturated (∑PUFAs), ∑n−6 and ∑n−3 fatty acids. In 7-day milk, the main effects were induced by VE supplementation that decreased ∑PUFAs, ∑n−6 and ∑n−3 and increased the Δ-6-desaturase activity. The VE+HXT supplementation resulted in lower desaturase capacity in 20-day milk. Positive correlations were observed between the estimated mean milk energy output and the desaturation capacity of sows. The lowest concentration of malondialdehyde (MDA) in milk was observed in VE-supplemented groups, whereas HXT supplementation increased oxidation. Milk lipid oxidation was negatively correlated with the sow’s plasma oxidative status and to a great extent with the oxidative status of piglets after weaning. Maternal VE supplementation produced a more beneficial milk composition to improve the oxidative status of piglets, which could promote gut health and piglet growth during the first weeks, but more research is needed to clarify this.