Mirari Arancibia

Synthetic plastic polymers are causing considerable emerging ecological hazards. Starch-based biofilms are a potential alternative. However, depending on the natural source and extraction method, the properties of starch can vary, affecting the physicochemical characteristics of the corresponding casted films generated from it. These differences might entail morphological changes at the nanoscale, which can be explored by inspecting their surfaces. Potato (Solanum tuberosum) is a well-known tuber containing a high amount of starch, but the properties of the biofilms extracted from it are dependent on the specific variety. In this research, four Ecuadorian potato varieties (Leona Blanca, Única, Chola, and Santa Rosa) were analyzed and blended with different glycerol concentrations. The amylose content of each extracted starch was estimated, and biofilms obtained were characterized at both macroscopic and nanoscopic levels. Macroscopic tests were conducted to evaluate their elastic properties, visible optical absorption, water vapor permeability, moisture content, and solubility. It was observed that as the glycerol percentage increased, both moisture content and soluble matter increased, while tensile strength decreased, especially in the case of the Chola variety. These results were correlated to a surface analysis using atomic force microscopy, providing a possible explanation based on the topography and phase contrast observations made at the nanoscale.

The replacement of synthetic polymers by starch biofilms entails a significant potentiality. They are non-toxic materials, biodegradable, and relatively easy to gather from several sources. However, various applications may require physicochemical properties that might prevent the use of some types of starch biofilms. Causes should be explored at the nanoscale. Here we present an atomic force microscopy surface analysis of starch biofilms extracted from the Andean tubers melloco (Ullucus tuberosus), mashua (Tropaeolum tuberosum), oca (Oxalis tuberosa), and potato (Solanum tuberosum) and relate the results to the macroscopic effects of moisture content, water activity, total soluble matter, water vapor permeability, elastic properties, opacity and IR absorption. Characterization reveals important differences at the nanoscale between the starch-based biofilms examined. Comparison permitted correlating macroscopic properties observed to the topography and tapping phase contrast segregation at the nanoscale. For instance, those samples presenting granular topography and disconnected phases at the nanoscale are associated with less elastic strength and more water molecule affinity. As an application example, we propose using the starch biofilms developed as a matrix to dispose of mouthwash and discover that melloco films are quite appropriate for this purpose.

In this study, edible packaging based on discarded green banana (Musa acuminata AAA) flour (whole banana and banana peel flours) was developed for food applications. Films were characterized in terms of film-forming ability, mechanical, barrier, thermal, microbiological, and sensory properties. The film forming solutions were studied for rheological properties. Two formulations were selected based on their film-forming ability: whole banana flour (2.5%), peel flour (1.5%) and glycerol (1.0 %, F-1.0 G or 1.5%, F-1.5 G). Adding 1.5% plasticizer, due to the hygroscopic effect, favored the water retention of the films, increasing the density, which also resulted in a decrease in lightness and transparency. Water activity shows no difference between the two formulations, which were water resistant for at least 25 h. DSC results showed a similar melting temperature (Tm) for both films, around 122 °C. Both films solutions showed a viscoelastic behavior in the frequency spectrum, being the elastic modulus greater in F-1.0 G film than F-1.5 G film at low frequency. F-1.0 G film was less firm, deformable and elastic, with a less compact structure and a rougher surface as confirmed by AFM, favoring a higher water vapor permeability with respect to F.1.5 G film. Microorganisms such as Enterobacteria and Staphylococcus aureus were not found in the films after a period of storage (1 year under ambient conditions). The F-1.0 G film with added spices (cumin, oregano, garlic, onion, pepper, and nutmeg) was tested for some food applications: as a snack (with or without heat treatment) and as a wrap for grilled chicken. The performance of the seasoned film during chilled storage of chicken breast was also studied. Sensory evaluation showed good overall acceptability of all applications. In addition, the chicken breast wrapped with the seasoned film registered lower counts (1-log cycle) than the control (covered with a polystyrene bag) and the film without spices. Green banana flour is a promising material to develop edible films for food applications.

Andean blackberries are highly perishable due to their susceptibility to water loss, softening, mechanical injuries, and postharvest diseases. In this study, the antimicrobial efficacy of gaseous ozone against spoilage (mesophiles, psychrotrophs, and yeasts and molds) and pathogenic (E. coli, S. enterica, and B. cinerea) microorganisms was evaluated during 10 days of storage at 6 ± 1 °C. Respiration rate and mass loss were also determined. Ozone was applied prior to storage at 0.4, 0.5, 0.6, and 0.7 ppm, for 3 min. The best results were observed with the higher ozone dose, with initial maximum reductions of ~0.5, 1.09, and 0.46 log units for E. coli, S. enterica, and B. cinerea, respectively. For the native microflora, maximum reductions of 1.85, 1.89, and 2.24 log units were achieved on day 1 for the mesophiles, psychrotrophs, and yeasts and molds, respectively, and this effect was maintained throughout storage. In addition, the lower respiration rate and mass loss of the blackberries ozonated at 0.7 ppm indicate that this treatment did not induce physiological damage to the fruit. Gaseous O₃ could be effective in maintaining the postharvest quality of blackberries throughout refrigerated storage but higher doses could be advisable to enhance its antimicrobial activity.

Ancestral Andean crop flours (ACF) from Ecuador such as camote (Ipomea Batatas), oca (Oxalis tuberosa), achira (Canna indica), mashua (Tropaeolum tuberosum), white arracacha (Arracacia xanthorrhiza), taro (Colocasia esculenta) and tarwi (Lupinus mutabilis sweet) were characterized in terms of physico-chemical and techno-functional properties in order to identify their potential as new alternative ingredients in food products. Flour from camote, oca, achira and arracacha showed a low protein content ( G″, this being very similar in camote, achira and tarwi flours. The exception was taro with G′ < G″. Mashua flour registered the highest value for phenol content (60.8 µg gallic acid equivalents/g of sample); the content of phenols was not exclusively responsible for the antioxidant activity, since flours with the highest activity were arracacha and tarwi, which presented the lowest phenol content among all flours. Principal component analyses (PCA) showed a high correlation between moisture, fiber, solubility and water absorption capacity, with viscoelastic behavior and total phenolic content; while starch content was correlated with melting temperature, poorly and inversely related to protein and fat. For PC1, achira, camote and taro flours were very similar, and different from oca and mashua flours. Tarwi showed its own characteristics according to PC1 and 2. Because of their properties, Andean crop flours could have a great potential for use in food technology.

The aim of this study was to determine the potential of Andean Crop Flours (ACF) to develop muffins suitable for people with celiac disease or gluten intolerance, as these flours do not contain gluten in their composition. The physico-chemical, rheological, microbiological and sensory properties of muffins from different blends of the following ACF were evaluated: camote (Ipomea batatas), oca (Oxalis tuberosa), achira (Canna indica) and mashua (Tropaeolum tuberosum), formulated with sucrose or sucralose. Wheat muffins with sucrose were used for control purposes. The effect of 5-day storage on color, texture and microbiology was also studied. The use of ACF sharply increased the amount of total dietary fiber, while fat and protein contents were slightly lower with respect to the control. Regarding color, formulations with ACF resulted in darker products, showing an important decrease in L* and b* values while a* increased in all ACF formulations. According to their rheological properties, all doughs showed an unstructured and viscous behavior, and the mixture of camote, achira and mashua with sugar was very similar to wheat muffin. On textural parameters, there was an increasing (p < 0.0) effect on firmness and chewiness noticeable on day 5 in all samples. The resultant muffins were considered safe products due to low counts of total microorganisms, molds and yeasts and the absence of Enterobacteria and Staphylococcus aureus during storage. Muffins with ACF showed good overall acceptability, especially muffins containing sucralose, which obtained the highest score. This study showed that ACF could be used as an alternative raw material in the preparation of gluten-free muffins with good nutritional quality, thus providing a useful alternative for underused crops.

The purpose of this work was to obtain chorizos by partially fat replacing with banana flour (whole or peeled). These chorizos were formulated with 3% pork fat and 24% whole banana flour (BC) or banana peel flour (BPC). A third formulation of chorizo with 15% pork fat and 12% wheat flour (WC) was also produced for comparison. Cooking loss was 12.5% for the WC, while for the BC and BPC chorizos it was 7.2% and 6.9%, respectively. All three products had similar water, protein, and ash contents, whereas carbohydrate and fiber contents were the main changes in composition. The color of the three different formulations did not change markedly, but an increase in yellowness and chromaticity was observed in the BC chorizo, as well as a slight decrease in lightness and in the whiteness index in the BPC one. Textural properties declined from day 0; from day 3 onwards, they remained constant in all chorizos and properties, except for BC lot in cohesiveness. Mesophilic aerobic bacteria, as well as mold and yeast counts, were predominantly high in the WC during chilled storage. Moreover, the sensory analysis indicated high acceptability of the formulated with wheat or whole banana flour, although those with banana peel flour scored slightly lower. This study shows that incorporating banana flours into the formulation successfully reduced the incorporation of pork back-fat, resulting in excellent quality sensorial characteristics due to the technological parameters and sensory acceptance.

This study aimed to develop a fiber-enriched Frankfurter-type sausage by incorporating underutilized green banana flours as a meat extender, replacing wheat flour with banana flours (8%). A low-fat formulation substituting 12% pork fat with 24% banana peel flour was also studied. Sausages were stored at 4 °C/15 days. Cooking loss was low (5.6–4.1%) in all formulations and the substitution of wheat flour with banana flour did not modify moisture and protein composition, while carbohydrate, fiber, and ashes varied with the flour composition. In the low-fat sausages, fiber carbohydrate and ashes increased the most. Texture and color parameters were very similar for high-fat sausages throughout storage, although low-fat sausage showed higher hardness, while chewiness, L*, and whiteness tended to decrease. During the first week of storage, the microbial growth was scarce and then, an increase, except in the low-fat batch, in which growth remained constant. Enterobacteria and Staphylococcus aureus were not detected during storage. Sensory attributes throughout storage were very similar for all high-fat sausages; the odor in the formulations was defined as “different” but not unpleasant. The low-fat sausages, defined as a new product different from conventional sausages, were well accepted by the panelist. Banana flours are a suitable ingredient option to add nutritional value to Frankfurter-type sausages, which can be consumed by the wheat allergic population.