Ariane Krause

Recycling nutrients is essential for closing nutrient loops within a circular economy. Using locally available resources such as human excreta to produce bio-based recycling fertilizers can substitute mineral fertilizers and thereby promote environmentally friendly food production. To better understand the fertilizer potential and nitrogen value of human excreta, three novel and safe recycling products were evaluated in a field experiment. Two nitrified urine fertilizers (NUFs) and one fecal compost were applied alone or in combination, and compared against the commercial organic fertilizer vinasse. In addition, the uptake of pharmaceuticals was assessed for treatments with compost application. White cabbage (Brassica oleracea var. capitata f. alba) was cultivated in plots in three different soil types (sand, loam or silt) treated with the fertilizers according to plant needs and mineral soil nitrogen content. The two NUFs resulted in marketable yields similar to those of vinasse in all soil types. Combining fecal compost with a NUF led to increased marketable yield compared to compost alone. The highest yield was recorded from the sandy soil, where vinasse and NUF treatments led to comparable yields, as expected in organic productions systems (up to 72 t ha⁻¹). The cabbage yield and total aboveground fresh biomass followed the following trend in all soils: NUFs ∼ vinasse ≥ compost + NUF ≥ compost. Nitrogen uptake in the cabbage heads and total biomass was significantly higher in sand (69.5–144 kg ha⁻¹) than loam (71.4–95.8 kg ha⁻¹). All compost treatments alleviated the effect of soil type and resulted in comparable nitrogen uptake and yield in all soil types. Plant uptake of pharmaceuticals (Carbamazepin) was higher in sand than in loam, and concentration in the edible part was lower than in the outer leaves. In conclusion, NUF alone appears to be a promising successful fertilizer substitute in horticultural food production. The combined application of NUF and compost led to slightly lower crop yields, but may increase soil carbon content in the long term, promoting climate-friendly food production.

Human excreta are a sustainable, economical source of nutrients, and can be used to produce recycling fertilizer for horticulture by collecting and processing the contents of dry toilets. Herein, we discuss the key categories of risk associated with the main groups of materials commonly found in dry toilets. The study was part of the development of a German product standard for marketable and quality-assured recycling fertilizers from human excreta for use in horticulture. Particular attention is paid to ensuring that the fertilizer is epidemiologically and environmentally harmless and that the quality of the recycling fertilizer is adequate in terms of low pollution and nutrient availability. In sum, the risk of transmissible human pathogens lies within the human excreta, particularly feces; plant materials added during composting are of particular phytosanitary relevance; pharmaceutical residues in excrements and chemical additives are potential sources of pollutants; non-biodegradable contaminants can cause pollution and injury; and the horticultural risks involve mainly the ammonia emission potential and in some cases the salinity effects of urine. These risks can be reduced significantly (i) with education of users around proper operation of dry toilets and the consequences of adding inappropriate waste, (ii) with facilitation of proper use with general waste bins and clear instructions, and importantly (iii) by using modern sanitization and cleaning processes and testing for harmful substances under the guidance of local laws and regulations, ensuring safe and high-quality fertilizers. In conclusion, the benefits of using dry toilet contents to produce fertilizers for use in horticulture are unquestionable. Our analysis highlights the need to support recycling optimization and awareness for the purpose of a sustainable circular economy and to minimize the risk of harm to humans and the environment overall.

A transformation towards sustainable food production requires improved circular nutrient management. Urban organic waste contains relevant nutrients and organic matter, yet only 4% of global urban nitrogen (N) and phosphorus (P) sources are presently recycled. One recycling approach is the composting of urban wastes for urban horticulture. We characterized compost from various urban waste fractions and assessed their fertilizer value in a pot trial with lettuce plants. Seven treatments were investigated: food waste vermicompost with coir and paperboard bedding material, thermophilic compost from green waste and human feces, two references with mineral fertilization and a sand control. The lettuce yield and total uptake of P, potassium (K), calcium (Ca), and magnesium (Mg) were highest in plants grown in coir-based vermicompost. The fecal compost led to the highest shoot P and K content, but the shoot uptake of Ca and Mg were lower than in the other treatments. All composts required additional N for lettuce growth. In conclusion, urban waste-derived vermicompost and fecal compost demonstrate a high delivery rate of plant-available Ca, Mg, P, and K. Research is needed on macronutrient availability and alternative N sources for the substitution of synthetic fertilization. These findings support the production of urban waste composts, furthering efforts in nutrient recycling.

The starting point of this work is the intention of two farmers’ initiatives to disseminate locally developed and adapted cooking and sanitation technologies to smallholder households in Karagwe District, in northwest Tanzania. These technologies include improved cooking stoves (ICSs), such as microgasifiers, and a system combining biogas digesters and burners for cooking, as well as urine-diverting dry toilets, and thermal sterilisation/pasteurisation for ecological sanitation (EcoSan). Switching to the new alternatives could lead to a higher availability of domestic residues for soil fertility management. These residues include biogas slurry from anaerobic digestion, powdery biochar from microgasifiers and sanitised human excreta from EcoSan facilities. Such recycling-driven approaches address an existing problem for many smallholders in sub-Saharan Africa, namely, the lack of soil amenders to sufficiently replenish soil nutrients and soil organic matter (SOM) in soils used for agricultural activity. This example from Tanzania systematically examines the nexus of ‘energy-sanitation-agriculture’ in smallholder farming systems. The short-term experiments demonstrated that all soil amenders that were analysed could significantly enhance crop productivity. CaSa-compost – the product of co-composting biochar with sanitised human excreta – quadrupled grain yields. The observed stimulation of crop yield and also plant nutrition is attributed to improved nutrient availability caused by a direct increase of soil pH and of plant-available phosphorus (P) in the soil. The assessment of the lasting soil implications revealed that CaSa-compost and biogas slurry both show the long-term potential to roughly double yields of maize. Corresponding nutrient requirements can be adequately compensated through residue capturing and subsistence production of soil amenders. The potential of CaSa-compost for sustainable soil fertility management is superior to that of standard compost, especially with respect to liming, replenishing soil P and restoring SOM. Biogas slurry, however, yields inferior results in all aspects when compared to compost amendments.

The average nutrient concentrations values presented in Table 1 on page 4 in the publication have the unit mg L−1 for the mineral nutrients Fe, Zn, B

Soilless culture systems offer an environmentally friendly and resource-efficient alternative to traditional cultivation systems fitting within the scheme of a circular economy. The objective of this research was to examine the sustainable integration of recycling fertilizers in hydroponic cultivation—creating a nutrient cycling concept for horticultural cultivation. Using the nutrient film technique (NFT), three recycling-based fertilizer variants were tested against standard synthetic mineral fertilization as the control, with 11 tomato plants (Solanum lycopersicum L. cv. Pannovy) per replicate (n = 4) and treatment: two nitrified urine-based fertilizers differing in ammonium/nitrate ratio (NH₄⁺:NO₃⁻), namely (1) “Aurin” (AUR) and (2) “Crop” (CRO); as well as (3) an organo-mineral mixture of struvite and vinasse (S+V); and (4) a control (NPK). The closed chamber method was adapted for gas fluxes (N₂O, CH₄, and CO₂) from the root zone. There was no indication in differences of the total shoot biomass fresh matter and uptake of N, P and K between recycling fertilizers and the control. Marketable fruit yield was comparable between NPK, CRO and S+V, whereas lower yields occurred in AUR. The higher NH₄⁺:NO₃⁻ of AUR was associated with an increased susceptibility of blossom-end-rot, likely due to reduced uptake and translocation of Ca. Highest sugar concentration was found in S+V, which may have been influenced by the presence of organic acids in vinasse. N₂O emissions were highest in S+V, which corresponded to our hypothesis that N₂O emissions positively correlate with organic-C input by the fertilizer amendments. Remaining treatments showed barely detectable GHG emissions. A nitrified urine with a low NH₄⁺:NO₃^– (e.g., CRO) has a high potential as recycling fertilizer in NFT systems for tomato cultivation, and S+V proved to supply sufficient P and K for adequate growth and yield. Alternative cultivation strategies may complement the composition of AUR.

To reduce the consumption of firewood for cooking and to realise recycling-driven soil fertility management, three projects in Northwest Tanzania aim to provide the local smallholder community with cooking and sanitation alternatives. The present study proposes an integrated approach to assess the sustainability of the small-scale cooking and sanitation technologies. Based on the multi-criteria decision support approach (MC(D)A), we developed a decision-specific, locally adapted, and participatory assessment tool: the Multi-Criteria Technology Assessment (MCTA). Pre-testing of the tailored tool was set up with representatives of Tanzanian and German partners of case study projects. From a methodological perspective, we conclude that the MCTA uses a set of relevant criteria to realise a transparent and replicable computational Excel-tool. The combination of MC(D)A for structuring the assessment with analytical methods, such as Material Flow Analysis, for describing the performance of alternatives is a promising path for designing integrated approaches to sustainability assessments of technologies. Pre-testing of the tool served as a proof-of-concept for the general design of the method. Future applications and adjustments of the MCTA require the inclusion of end-users, a reasonable and participatory reduction of criteria, and an increase of feedback loops and group discussions between participants and the facilitator to support a common learning about the technologies and thorough understanding of the perspectives of participants. , Author(s): Ariane Krause and Johann Köppel, Category: Articles, Pages: 1-19

Residues from bioenergy and ecological sanitation (EcoSan) can be utilized to sustain soil fertility and productivity. With regard to certain cooking and sanitation technologies used in smallholder households (hh), we systematically analyzed how utilization of the respective potentials to recover residues for farming affects (i) soil nutrient balances, (ii) the potential for subsistence production of composts, and (iii) environmental emissions. On the example of an intercropping farming system in Karagwe, Tanzania, we studied specific farming practices including (1) current practices of using standard compost only; (2) a combination of using biogas slurry, urine, and standard compost; (3) a combination of using so-called “CaSa-compost” (containing biochar and sanitized human excreta, Project “Carbonization and Sanitation”), urine, and standard compost. The system analysis combines a soil nutrient balance (SNB) with material flow analysis (MFA). Currently, nitrogen (N) and phosphorus (P) are depleted by −54 ± 3 and −8 ± 1 kg∙ha⁻¹∙year⁻¹, respectively. Our analysis shows, however, a clear potential to reduce depletion rates of N, and to reverse the SNB of P, to bring about a positive outcome. Composts and biogas slurry supply sufficient P to crops, while urine effectively supplements N. By using resources recovered from cooking and sanitation, sufficient compost for subsistence farming may be produced. Human excreta contribute especially to total N and total P in CaSa-compost, whilst biochar recovered from cooking with microgasifier stoves adds to total carbon (C) and total P. We conclude that the combined recycling of household residues from cooking and from sanitation, and CaSa-compost in particular, is especially suitable for sustainable soil management, as it mitigates existing P-deficiency and soil acidity, and also restores soil organic matter.