Joo Hwa Tay

This study investigated structural changes in microbial community of biological nutrient removal (BNR) in response to changes in substrate composition (ammonium and phosphate), redox condition, and morphological characteristics (flocs to granules), with a focus on nitrification and phosphate removal. Analyzing treatment performance and 16S rRNA phylogenetic gene sequencing data suggested that heterotrophic nitrification (HN) and autotrophic nitrification (AN) potentially happened in aerobic organic-rich (HN_AS) and aerobic organic-deficient (AN_AS) activated sludge batch reactors, respectively. However, phosphate release and uptake were not observed under alternating anaerobic/aerobic regime. Phosphate release could not be induced even when anaerobic phase was extended, although Accumulibacter existed in the inoculum (5.1% of total bacteria). Some potential HN (e.g., Thauera, Acinetobacter, Flavobacterium), AN (e.g., Nitrosomonas (3.2%) and Nitrospira), and unconventional phosphate-accumulating organisms (PAOs) were identified. Putative HN bacteria (i.e., Thauera (29–36%) and Flavobacterium (18–25%)) were enriched in aerobic granular sludge (AGS) regardless of the granular reactor operation mode. Enrichment of HN organisms in the AGS was suspected to be mainly due to granulation, possibly due to the floc-forming ability of HN species. Thus, HN is likely to play a role in nitrogen removal in AGS reactors. This study is supposed to serve as a starting point for the investigation of the microbial communities of AS- and AGS-based BNR processes. It is recommended that the identified roles for the isolated bacteria are further investigated in future works.

The wastewater of the industrial production of artificial sweetener sucralose contained an average 1100 mg/L of total organic carbon (TOC) with 2100 mg/L of chemical oxygen demand and 10 mg/L of biological oxygen demand. Biodegradability of the wastewater components was low due to chlorinated organic substances. The combined chemical and biological treatment of this wastewater in the bioreactors with hematite iron ore removed up to 70% of TOC. About 20% of TOC was removed quickly by adsorption on iron ore particles, but adsorption/precipitation of others up to 50% of TOC was due to ferrous/ferric ions and hydroxides produced during microbial reduction and dissolution of iron ore. The calculated dosage of iron ore with 150 regeneration cycles could be 46.7 g/L of wastewater. Thus, the treatment of wastewater with iron ore and iron-reducing bacteria diminished the quantity of granulated activated carbon that is used in the treatment of sucralose production wastewater by up to 70%.

Aerobic granules are the potential tools to develop modern wastewater treatment technologies with improved nutrient removal efficiency. These granules have several promising advantages over conventional activated sludge-based wastewater treatment processes. This technology has the potential of reducing the infrastructure and operation costs of wastewater treatment by 25%, energy requirement by 30%, and space requirement by 75%. The nutrient removal mechanisms of aerobic granules are slightly different from that of the activated sludge. For instance, unlike activated sludge process, according to some reports, as high as 70% of the total phosphorus removed by aerobic granules were attributed to precipitation within the granules. Similarly, aerobic granule-based technology reduces the total amount of sludge produced during wastewater treatment. However, the reason behind this observation is unknown and it needs further explanations based on carbon and nitrogen removal mechanisms. Thus, as a part of the present review, a set of new hypotheses have been proposed to explain the peculiar nutrient removal mechanisms of the aerobic granules.

Aerobic granules were discovered around 20 years back.

Abstract This study investigated the feasibility of using freeze-dried biogranules in lagoon basins. The effect of different operational conditions on treatment performance and detention time of granule-based lagoons was examined in a series of laboratory-scale batch studies. Optimal granule dosage was 0.1 g/L under anaerobic condition, resulting in 80–94% removal of 1000 mg/L chemical oxygen demand (COD) in 7–10 days. Under aerobic condition, granule dosage of 0.2 g/L achieved the best result for identical COD concentration. However, adequate amount of nutrients (optimal COD/N/P ratio of 100/13/0.8) should be supplied to encourage the growth of aerobic species. At optimal COD/N/P ratio, aerobic treatment interval significantly reduced to 2–3 days with corresponding COD removal efficiency of 88–92%. Inhibition of high concentrations of COD (5000 mg/L) and ammonia (480 mg/L NH₄-N) was observed on microbial activity and treatment capacity of the biogranules. Mixing was a crucial measure to overcome mass transfer limitation. Onetime inoculation of lagoon with fresh granules was the best approach to achieve a satisfactory treatment efficiency. This study suggested that utilization of the biogranules is a feasible and sustainable technique for augmenting lagoon plants in terms of improved effluent quality and reduced retention time. ᅟ

The membrane bioreactor (MBR) has emerged as an efficient compact technology for municipal and industrial wastewater treatment. The major drawback impeding wider application of MBRs is membrane fouling, which significantly reduces membrane performance and lifespan, resulting in a significant increase in maintenance and operating costs. Finding sustainable membrane fouling mitigation strategies in MBRs has been one of the main concerns over the last two decades. This paper provides an overview of membrane fouling and studies conducted to identify mitigating strategies for fouling in MBRs. Classes of foulants, including biofoulants, organic foulants and inorganic foulants, as well as factors influencing membrane fouling are outlined. Recent research attempts on fouling control, including addition of coagulants and adsorbents, combination of aerobic granulation with MBRs, introduction of granular materials with air scouring in the MBR tank, and quorum quenching are presented. The addition of coagulants and adsorbents shows a significant membrane fouling reduction, but further research is needed to establish optimum dosages of the various coagulants/adsorbents. Similarly, the integration of aerobic granulation with MBRs, which targets biofoulants and organic foulants, shows outstanding filtration performance and a significant reduction in fouling rate, as well as excellent nutrients removal. However, further research is needed on the enhancement of long-term granule integrity. Quorum quenching also offers a strong potential for fouling control, but pilot-scale testing is required to explore the feasibility of full-scale application.