Laura Purriños

Global population growth is putting pressure on the food supply, necessitating the exploration of new, alternative, and sustainable protein sources. Lupin, an underutilized legume in human nutrition, has the potential to play a significant role in addressing this challenge. However, its incorporation into the human diet requires thorough investigation, including exploring and optimizing functionalization processes to maximize its potential. This study aimed to optimize the parameters (pressure, time, and CO₂ flow) for extracting anti-technological factors (ATFs) from lupin using supercritical CO₂ (SC-CO₂) and to evaluate the effects of this extraction on both the flour and the protein isolate derived from it. Optimization revealed that the optimal SC-CO₂ conditions were a CO₂ flow rate of 4 kg/h at 400 bar for 93 min. Under these conditions, significant changes were observed in the flour composition, including a reduction in oil, polyphenols, and moisture content, along with an increase in ash content. Improved color parameters were also noted. These variations were attributed to the removal of oil and phenolic compounds during processing. Furthermore, this research demonstrated that SC-CO₂ treatment improved lupin protein isolate (LPI) purity (93.81 ± 0.31% vs. 87.42 ± 0.48%), significantly reduced oil content (8.31 ± 0.09% vs. 14.31 ± 0.32%), and enhanced color parameters. The SC-CO₂ procedure also resulted in a higher protein extraction yield (56.95 ± 0.45% vs. 53.29 ± 2.37%). However, the total extraction yield (g LPI/100 g of flour) was not affected by SC-CO₂ treatment, remaining at 24.30 ± 0.97% for the control sample and 24.21 ± 0.26% for the treated sample. The extracted oil (2.71 ± 0.11 g/100 g of flour), a co-product of the SC-CO₂ step, exhibited a fatty acid profile characterized by high levels of unsaturated fatty acids (62.8 ± 0.74 g/100 g oil), oleic acid (27.76 ± 0.77 g/100 g oil), linoleic acid (25.98 ± 0.73 g/100 g oil), and α-linolenic acid (5.32 ± 0.16 g/100 g oil), as well as a balanced ratio of essential fatty acids (n-6/n-3 = 4.89). The treatment had minimal to no effect on amino acid content or chemical score, and the protein was characterized by high amounts of essential amino acids (334 ± 3.12 and 328 ± 1.05 mg/g protein in LPI-control and LPI-SF, respectively). These findings demonstrate that both the LPI and the oil extracted using SC-CO₂ possess high nutritional quality and are suitable for human food applications.

The aim of this study was to assess the impact of tomato pomace (TP) on the content of volatile compounds and L-carnitine and the sensory characteristics of raw fermented sausages produced with reduced nitrite. The produced sausages were divided into three experimental groups: control sample, sample with 1.5% addition of freeze-dried tomato pomace, and sample with 2.5% addition of TP. The results showed that the addition of tomato pomace significantly affected the quality of raw fermented sausages. Lower L-carnitine content was observed in samples with TP. The main groups of volatile compounds identified in fermented sausages were alcohols, aldehydes, hydrocarbons, and ketones. The addition of TP influenced the smell and taste of the sausages, which were characterized by a more intense tomato taste and smell and more intense red color compared to the control sample. Despite the influence of TP addition on some sensory features, the products were characterized by a high score of overall quality of over 7 c.u. on a 10-point scale, similar to the control sausage.

Today’s society demands healthy meat with a special emphasis on integrated animal husbandry combined with the concern for animal welfare. In this sense, the raising of lambs in an extensive system has been one of the most common practices, which results in meats with high nutritional value. However, both the production system and the diet play a fundamental role in the chemical composition of the meat, which has a direct impact on the content of volatile compounds. Thus, the aim of this study was to determine the effect of two production systems (intensive and extensive) on the chemical composition and volatile profile of lamb meat. Twenty-eight lambs of the Bordaleira-de-Entre-Douro-e-Minho (BEDM) sheep breed were raised for meat production under the intensive or extensive system and were fed with concentrate and pasture, respectively. All animals were carried out in the muscle longissimus thoracis et lumborum. Results evidenced that all the composition parameters were affected by the production system. Extensively-reared lambs produced meat with the highest fat and protein contents, while these animals had the lowest percentages of moisture and ash. Similarly, the total content of volatile compounds was affected (p < 0.05) by the production system and were higher in the meat of lambs reared extensively. Furthermore, the content of total acids, alcohols, aldehydes, esters, ethers, furans and sulfur compounds as well as most of the individual compounds were also affected (p < 0.05) by the production system, whereas total hydrocarbons and ketones were not affected (p > 0.05). As a general conclusion, the production system had very high influence not only in proximate composition but also in the volatile compounds.

Mansa and Brava are olive autochthonous cultivars from Galicia, a new olive-growing zone from NW Spanish, from which high-quality extra virgin olive oils (EVOOs) are obtained. The oils obtained as by co-crushing Mansa and Brava olives in different proportions as by blending with others olives cultivars have different composition that influence in their sensory quality. The consumer acceptance of commercial oils elaborated with Local Galician cultivars was evaluated and a quality-mapping of olive oils was created. It was found that the both Local oils had good physical-chemical quality parameters. From sensory analysis viewpoint, Local-MB oils presented the highest intensity values for color, odor, taste, and flavor, and the consumers had a higher acceptance and preference by Picual, Local-MBPA (60% Mansa and Brava, 25% Picual, and 15% Arbequina and Local-MB (60% Mansa and 40% Brava) oils. A quality-mapping of olive oils indicate that attributes better scored from the consumer are high intensity for color, odor, taste and flavor, and pungent and floral series, and bitter is rejected by them.

Different bovine breeds and production systems are used worldwide, giving rise to differences in intrinsic and extrinsic characteristics of beef. In order to meet the consumer requirements, new approaches are currently being developed to guarantee tenderness, taste, and juiciness of beef. However, the final consumer perception is complex, and it is also affected by several interrelated variables. This study aimed to evaluate the physicochemical parameters and sensory profile of three Spanish cattle breeds under different livestock production systems (extensive and intensive) and pre-slaughter handling conditions (mixing and not mixing with unfamiliar individuals at pre-mortem time). Meat samples from each group were also studied at different ageing times (7 and 14 days). Regarding sensory attributes, twelve panelists assessed meat samples and an exhaustive statistical analysis was carried out. The most evident and strongest effect was the breed type, allowing a great differentiation among them using principal components and discriminant analysis. The livestock production system was the second most important parameter, significantly affecting odor, flavor, and textural profile (fibrousness). It can be concluded that there were marked differences in the traits of these beef that could be modified by other factors in order to fulfill consumer tastes.

Different health institutions from western countries ha–ve recommended a diet higher in polyunsaturated fats, especially of the n-3 family. However, this is not a trivial task, especially for meat-processing sectors. The objective of this work was to assess the influence of replacing pork backfat with linseed oleogel on the main quality parameters of frankfurters. The frankfurters were formulated by the pork backfat replacement of 0% (control), 25% (SF-25), and 50% (SF-50), using a linseed oleogel gelled with beeswax. The determination of quality parameters (pH, colour, chemical composition, and texture parameters), the fatty acid profile, and the sensory evaluation was carried out for each batch. The fatty acid profile was substantially improved, and the saturated fatty acid (SFA) content was reduced from 35.15g/100g in control sausages to 33.95 and 32.34g/100 g in SF-25 and SF-50, respectively, and more balanced ratios n-6/n-3 were achieved. In addition, the sausages with linseed oleogel also decreased the cholesterol content from 25.08 mg/100 g in control sausages to 20.12 and 17.23 mg/100 g in SF-25 and SF-50, respectively. It may therefore be concluded that these innovative meat products are a healthier alternative. However, sensory parameters should be improved in order to increase consumer acceptability, and further research is needed.