Ulrike Zitz

High quality raw milk is an important prerequisite for the production of long ripened raw milk cheeses. This implies not only the absence of pathogenic microorganisms in raw milk, but also low levels of spoilage bacteria, including dairy propionic acid bacteria (dPAB), that can cause blowing and sensory defects in cheese, resulting in severe economic losses for producers. Raw milk contamination with dPAB has been primarily associated with improperly cleaned milking systems, but they have been detected in feed, soil, feces and on the teat skin. The objective of this study was to identify potential sources of raw milk contamination with dPAB in the barn and milking parlor environments. We also wanted to know more about the prevalence of the dPAB species in these environments and the levels of contamination. For this purpose, 16 small scale Alpine dairy farms were visited in August 2022: samples were taken from the barn environment (e.g., swab samples, air, feed, bedding), the milking system (swab samples, residual cleaning water, cleaning sponges, milk filters) and milk samples were collected at various sampling points along the milking system. Samples were analyzed for dPAB contamination, and results showed contamination at multiple sampling locations. We observed potential adverse effects of improperly set cleaning parameters of the milking system, as well as of farm specific practices. In addition, we identified cleaning water residues as an important source of contamination. Based on these findings, we propose potential mitigation strategies to reduce the risk of raw milk contamination with cheese spoilage bacteria, thereby contributing to a more sustainable food production.

Even low levels of dairy propionic acid bacteria (dPAB) can cause cheese defects, resulting in severe economic losses for the producers of selected raw milk cheeses. Therefore, routine quality control of raw cheese milk for dPAB contamination is essential if propionic acid fermentation is undesired. Although knowledge of dPAB contamination of raw milk is important to understand cheese spoilage, long-term dPAB screening data are outdated, and studies taking into account different farm management parameters and their potential influence on dPAB levels are scarce. This study aims to provide insight into the dPAB levels of raw milk over time, to identify farm management factors that potentially influence dPAB levels, and to compare a cultural yeast extract lactate agar (YELA) and lithium glycerol agar (LGA) and a culture-independent method (qPCR) for dPAB quantification with respect to their applicability in routine quality control for the dairy industry. For this purpose, bulk tank milk from 25 dairy farms was screened for dPAB contamination over a one-year period. We were able to identify significant differences in the dPAB contamination levels in raw milk depending on selected farm-specific factors and observed relationships between the different types of milking systems and dPAB contamination levels in raw milk. When dPAB were quantified by cultivation on YELA, strong overgrowth of commensal microbiota impeded counting. Therefore, we conclude that quantification on LGA or by qPCR is preferable. Both methods, colony counting on LGA as well as quantification of dPAB using qPCR, have advantages for the application in (routine) quality control of raw milk, one being low-tech and inexpensive, the other being fast and highly specific, but the detection of (low level) dPAB contamination in raw milk remains a challenge.

Enumeration of endospores of butyric acid-forming clostridia in cheese milk is an essential part of milk quality monitoring for cheese producers to avoid late blowing, severe spoilage caused by clostridia during ripening. However, due to the lack of an internationally standardized method, different methods are used and it is important to consider how the choice of method affects the results. This is particularly relevant when clostridial spore counts in milk are considered for quality payments. The aim of this study was to evaluate the specificity of the AMP-6000 method for the enumeration of endospores of cheese spoiling clostridia in milk. First, to assess the prevalence of Clostridium diversity and to determine potential non-target species, we identified isolates from positive reactions of the AMP-6000 method used to quantify clostridial endospores in raw milk and teat skin samples by MALDI-TOF MS. Based on these results, a strain library was designed to evaluate method inclusivity and exclusivity using pure cultures of target and non-target strains according to ISO 16140-2:2016. Most target Clostridium tyrobutyricum strains, as well as all tested C. butyricum and C. sporogenes strains were inclusive. However, C. beijerinckii may be underestimated as only some strains gave positive results. All non-target strains of bacilli and lysinibacilli, but not all paenibacilli, were confirmed to be exclusive. This study provides performance data to better understand the results of microbiological enumeration of butyric acid-forming clostridia in milk and serves as a basis for future methodological considerations and improvements.

Butyric acid producing clostridia (BAPC) cause the so-called late-blowing defect, a serious quality problem in semi-hard and hard cheeses. Late-blown cheeses are characterized by undesired slits and cracks, irregular eyes, and off-flavors due to excessive amounts of gas and organic acids produced by clostridia. Clostridial transfer to raw milk can occur during milking through dirty teats. Therefore, teat cleaning before milking is a key factor in preventing clostridial contamination of the milk. However, different cleaning methods are used, and little information is available on the efficacy of routine teat cleaning in reducing clostridial endospores. The main objectives of this study were to assess the extent of udder contamination with BAPC spores and to investigate the efficacy of routine teat cleaning on BAPC spore counts in milk. In a longitudinal study, eight dairy farms were visited during five sampling events. Clostridial spore counts were quantified from teat skin before and after routine teat cleaning, in pooled quarter milk samples from individual cows, and in bulk tank milk samples using a most probable number method. In addition, farm management data were collected periodically through a survey, and average cow cleanliness was assessed by a veterinarian. On average, teat cleaning resulted in a 0.6 log unit reduction in BAPC spores on teat skin, and a strong positive correlation was found between BAPC spore concentrations on teat skin after cleaning and in pooled quarter milk samples. Seasonal variations and the potential influence of differences in farm management were also noted. Interestingly, average cow cleanliness correlated strongly with BAPC spore levels in milk, suggesting the potential for a quick and rough estimation method of clostridial contamination that could be implemented by farmers.

For decades, microorganisms in beet sugar production have been studied using culture-based methods. However, these methods are not sufficient to describe such a complex bacterial community. In this study, therefore, an amplicon-based sequencing technique (Illumina MiSeq platform) was applied to characterize the bacterial community and its dynamics in the extraction area and juice purification station of an Austrian beet sugar plant. Depending on the process conditions thermophilic bacteria, such as Geobacillus spp., Caenibacillus spp., and Thermus spp., and mesophilic bacteria, such as Leuconostoc spp. and Bacillus spp., were found. Besides these microbiological characteristics, the antimicrobial effect of a rosin acid-based product (Defostab 220) on the bacterial communities was investigated in industrial and laboratory trials. The antimicrobial effect of a given concentration of rosin acid varies from bacteriostatic to bactericidal effects on different occurring groups of bacteria.

Naturally fermented foods are an important part of the typical diet in Cambodia. However, the food safety status of these products has not been widely studied. The aim of this study was, therefore, to provide an overview of the quality of these foods in relation to microbiology and biogenic amines. Additionally, the obtained results were compared to the habits and practices of Cambodians in handling this type of food. A total of 57 fermented foods (42 fishery and 15 vegetable products) were collected from different retail markets in the capital of Cambodia. Pathogenic Salmonella spp., Listeria spp., and Listeria monocytogenes were not detected in 25 g samples. Generally, less than 10² cfu/g of Staphylococcus aureus, Escherichia coli, Pseudomonas spp., Enterobacteriaceae, and molds were present in the fermented foods. Bacillus cereus group members (2 to 2.3 × 10⁴ cfu/g), lactic acid bacteria (2 to 1.1 × 10⁷ cfu/g), halophilic and halotolerant bacteria (2 to 8.9 × 10⁶ cfu/g), sulfite-reducing Clostridium spp. (2 to 3.5 × 10⁶ cfu/g), and yeasts (500 ppm) and tyramine (>600 ppm) were higher than the recommended maximum levels in respectively four and one of 57 fermented foods, which represents a potential health risk. The results suggest that the production process, distribution, and domestic handling of fermented foods should be re-evaluated. Further research is needed for the establishment of applicable preservation techniques in Cambodia.