Monika Grasser

Since the human population is continuously growing, sufficient food with low environmental impact is required. Especially, the challenge of providing proteins will deepen and insects can contribute to a more sustainable and efficient source of protein for human consumption. Tenebrio molitor larvae are highly nutritious and rearing mealworms is more environmentally friendly compared to the production of traditional livestock meat. To use T. molitor as a more sustainable alternative to conventional proteins, it is essential to apply diets from a local and sustainable source. Therefore, the objective of this study was to find local by-products or leftovers which can be used in mass production of larvae as a main substrate. Feeding trials investigating twenty-nine different substrates were conducted to evaluate larval growth performance and adult reproduction by determining development times, survival rates, biomass, and fecundity. Several suitable by-products were identified that can be used in high quantities as single component diet for T. molitor rearing, revealing a high survival rate, short development time, high mean total biomass, and successful breeding. The most successful substrate—malt residual pellets—was found to be an alternative to the most used substrate, wheat bran. Furthermore, corn germ meal, sweet chestnuts, bread remains, soybeans, sweet potatoes, and wheat germs have been discovered to be suitable diets for T. molitor. Moreover, the findings of this study contribute towards using several substrates as supplements.

As a result of the increasing focus on alternative protein sources which are ideally still sustainable, the yellow mealworm, Tenebrio molitor, has come into focus. To verify its suitability as a food source in relation to human health, an analysis of the microbiome of larvae of T. molitor is pertinent. Subsequently, the focus of this study was, on the one hand, to analyze the influence of the substrate on the microbial load of the larvae microbiome, and, on the other hand, to determine which processing methods ensure the risk-free consumption of mealworms. For this purpose, mealworms were grown on 10 different substrates derived from by-products of food production (malt residual pellets, corn germ meal, chestnut breakage and meal, wheat bran, bread remains, draff, nettle, hemp seed oil cake, oyster mushrooms with coffee grounds, pumpkin seed oil cake) and microbial loads were analyzed using different selective media. Further starvation/defecation and heating (850 W for 10 min) methods were used to investigate how the reduction of microorganisms is enabled by these methods. The results showed that there was no significant relationship between the microbial load of the substrate and the mealworm. Starvation and defecation led to a lower stock of microorganisms. Heating led to a significant microbial reduction in non-defecated mealworms. The group of defecated and heated mealworms showed no detectable microbial load. In conclusion, firstly, the choice of substrate showed no effect on the microbial load of larvae of Tenebrio molitor and secondly, heating and starvation allow risk-free consumption. This study makes an important contribution for evaluating the safety of mealworms as a sustainable protein source in human nutrition.

Future food systems must provide more food produced on less land with fewer greenhouse gas emissions if the goal is to keep planetary boundaries within safe zones. The valorisation of agricultural and industrial by-products by insects is an increasingly investigated strategy, because it can help to address resource scarcities and related environmental issues. Thus, insects for food and feed have gained increasing attention as a sustainable protein production strategy in circular food systems lately. In this article, we provide an overview on by-products, which have already been fed to T. molitor (mealworms), a common edible insect species. In addition, we investigate other by-products in Austria, which can be suitable substrates for T. molitor farming. We also provide an overview and discuss different perspectives on T. molitor and link it with the circular economy concept. We identify several future research fields, such as more comprehensive feeding trials with other by-products, feeding trials with mealworms over several generations, and the development of a standardized framework for insect rearing trials. In addition, we argue that due to their ability to convert organic by-products from agricultural and industrial processes into biomass in an efficient way, T. molitor can contribute towards resource-efficient and circular food and feed production. However, several hurdles, such as legal frameworks, need to be adapted, and further research is needed to fully reap the benefits of mealworm farming.