James F. Campbell

In recent years, there has been an increasing interest and need for alternatives to structural fumigations, and one alternative that has been used across the industry is aerosol insecticides. Previous tests inside a pilot-scale mill demonstrated that aerosol particle size, delivery method, and the spatial configuration of the mill all influenced effectiveness. However, there is no research conducted inside large commercial facilities. The objective of this research was to evaluate a pyrethrin-plus-methoprene aerosol application inside a commercial mill on adult Tribolium confusum Jacquelin duVal, confused flour beetle, directly exposed to the aerosol and residual effects on larvae. Additionally, five aerodynamic particle sizer spectrometers were placed in the facility and recorded instantaneous spray concentration and estimated aerosol deposition. Adult T. confusum exposed nearest to the aerosol application points had the highest percentage of affected adults (>60%). The aerosol also had vertical movement when released at the top of a three-story open room; instantaneous concentrations were recorded on the ground floor. The aerosol residual was highly effective after 6-weeks post aerosol exposure, as 80% of the bioassays did not have any adult emergence from exposed larvae. This research demonstrates a practical use of aerosol insecticides and their potential to be an effective alternative to structural fumigations.

Residual effects of pyrethrin + methoprene aerosol dispensed at 4 and 16-µm particle sizes and an untreated control, was assessed against late-stage larvae of Trogoderma inclusum (LeConte), the larger cabinet beetle, and T. variabile (Ballion), the warehouse beetle. Treated arenas were stored at 25, 30, 35, and 40 °C and bioassays were conducted at 1, 3, or 6 weeks post-treatment. Larval development was monitored through adult emergence to compare the efficacy of treatments by using both the percentage of normal adult emergence and a developmental index as dependent variables. There was no overall effect of temperature on residual activity as measured using either adult emergence or developmental index values. Both the 4 and 16-µm particle sizes resulted in reduced adult emergence and low developmental index values compared to untreated controls. The insecticide was more effective on T. variabile than on T. inclusum. The impact of particle size varied between species, both particle sizes reduced adult emergence and developmental index in T. variabile, but only the 16-µm particle size resulted in reduction of adult emergence of T. inclusum. Furthermore, there was a reduction in activity of methoprene with residual exposure time. The variations in susceptibility of species to methoprene, differences in efficacy of particle sizes, and decrease in residual persistence at smaller particle sizes highlight the need for attaining optimal particle size to improve overall efficacy of aerosol mixtures containing methoprene.

Fumigation of grain bins with phosphine tablets is one method of insect control for stored products. Monitoring the concentration of the toxic gas at many locations over several days for a given structure or container can be challenging. In this study, a commercially-available system that wirelessly measures phosphine was evaluated in small-scale and large-scale tests. Small-scale testing was performed to study the repeatability and accuracy of the sensors. The wireless sensors were within 30 ppm of each other, over a range of 700 ppm phosphine. Large-scale testing evaluated the system during the fumigation of wheat stored in 7 m diameter, 120 metric ton, steel grain bins. As a reference, monitoring lines were distributed at several positions and depths in the bin in order to sample phosphine gas concentrations. A series of three fumigation trials were performed, with each lasting for over six days. The wireless devices collected local phosphine concentrations and temperatures every two hours without assistance from personnel. Although the fumigation trials were significantly different in terms of patterns in gas concentration over time, the two sampling methods gave similar trendlines. However, the automated data provided a more detailed picture of the fumigation process. This information may help fumigation managers to better evaluate fumigations and assure successful insect control.

Insects can infest facilities that house and process post-harvest grains and grain-based products. Integrated pest management tactics rely on tracking insect populations and using this information to select and target management tactics. Our ability to predict when and where to best focus treatment relies on an understanding of long-term trends, but often any available monitoring data are limited in its duration. Here we present data collected over a 10-year period at a flour mill in the central part of the United States. Using traps placed both inside and outside a flour mill and baited with pheromone-lures for Plodia interpunctella (Hübner), Indianmeal moth, and Trogoderma variabile Ballion, warehouse beetle, we examine environmental and spatial variability in insect captures. We find that both species, inside and outside the mill, are highly influenced by seasonal patterns, with peaks of insect captures during the warm season (April through September). There is also consistency across time and space in trap capture for P. interpunctella with traps in an open location consistently capturing high numbers of insects. In contrast, T. variabile lacked consistency in trap capture but were most often not found in the same trap locations as P. interpunctella. Fumigations conducted within the facility appeared to have little impact on insect captures inside, with dynamics appearing to be driven more by broader seasonal patterns in activity. These data and analyses suggest that there is a larger population of these insects that are readily moving in and out of the structures, while fumigation treatments are only impacting a small portion of the overall population and tactics targeting immigration may be an important addition to the pest management program.

The temporal and spatial patterns in flight activity outside of a rice mill were evaluated for the lesser grain borer [Rhyzopertha dominica (F.)], warehouse beetle [Trogoderma variabile Ballion], cigarette beetle [Lasioderma serricorne (F.)], and Indian meal moth [Plodia interpunctella (Hüϋbner)] to determine critical times of year when the mill would be vulnerable to invasion. Insect activity was monitored using pheromone-baited glue traps (N = 99) from June 2008 to October 2010. Traps were placed along exterior walls of all major buildings and along the fence around the perimeter of the facility. Trogoderma variabile was the most abundant species, with flight activity between mid-March and November. No activity of T. variabile was observed during December through March. Rhyzopertha dominica was also abundant, with activity in mid-April through October. A few adult R. dominica were captured in traps during winter months in the first year of study. Trap captures for all four species increased with an increase in temperature and can be described by linear equations. Knowing seasonal patterns in insect activity allows rice facilities to better understand when facilities are most vulnerable to pest activity. However, this study demonstrates that more research is needed to address how insects are immigrating and emigrating within and around a rice mill.

In trapping programs prior capture of individuals of the same or different species may influence subsequent attractiveness of the trap. To evaluate this process with stored-product insects, the effect of the presence of dead or alive adults in traps on the behavioral responses of six stored-product insect species, Tribolium confusum Jacquelin du Val, T. castaneum (Herbst) (Coleoptera: Tenebrionidae), Sitophilus oryzae (L.), S. granarius (L.) (Coleoptera: Curculionidae), Oryzaephilus surinamensis (L.) and O. mercator (Fauvel) (Coleoptera: Silvanidae), was studied in choice tests under laboratory conditions. Two series of tests were carried out. In the first series, the choice was between either alive or dead adults of same species and blank (no adults). Overall, dead adults had the strongest influence, increasing the response of S. oryzae, S. granarius, O. surinamensis, and O. mercator and decreasing the response of the two Tribolium species. Presence of alive adults generally did not result in a response different from blank, except for T. castaneum and O. surinamensis that had a reduced response. In the second series of tests, the choice was between alive or dead individuals of the species vs. alive or dead individuals of its relative cogeneric species. For choices between alive individuals, S. oryzae, S. granarius, and O. surinamensis showed a preference for alive individuals of the same species vs. the cogeneric species, and for all the other species there was no preference. For choices between dead individuals, T. castaneum exhibited a preference for individuals of the same species, while S. oryzae, S. granarius, and O. mercator showed a preference for individuals of the cogeneric species, and all other combinations did exhibit a preference. Our results suggest that traps containing alive and dead individuals of the same and other species can seriously affect the response and capture of additional insects.

Grain stored in bins is initially a relatively homogenous resource patch for stored-product insects, but over time, spatial pattern in insect distribution can form, due in part to insect movement patterns. However, the factors that influence stored-product insect movement patterns in grain are not well-understood. This research focused on the movement of the lesser grain borer, Rhyzopertha dominica (F.), within a simulated wheat grain mass (vertical monolayer of wheat) and the identification of factors that contribute to overall and upward movement (age since adult emergence from an infested kernel [1, 7, and 14 d], sex, strain, and different levels of environment quality). We also used the model selection approach to select the most relevant factors and determine the relationships among them. Three-week-old adults tended to stay closer to the surface compared with 1- or 2-wk-old insects. Also, females tended to be more active and to explore a larger area compared with males. Explored area and daily displacement were also significantly strain-dependent, and increasing grain infestation level decreased daily displacement and explored area. Variation in movement pattern is likely to influence the formation of spatial pattern and affect probability to disperse. Understanding movement behavior within a grain bin is crucial to designing better strategies to implement and interpret monitoring programs and to target control tactics.

The impact of prior captures on the trapping performance of floor traps was evaluated for the red flour beetle, Tribolium castaneum (Herbst) (Coleoptera: Tenebrionidae), and the confused flour beetle, Tribolium confusum Jacquelin du Val (Coleoptera: Tenebrionidae), in laboratory conditions. The effect of trap seeding, adding adults of the same or different species, was evaluated in order to determine possible effects of prior captures in the trap on each species' behavioral responses. The presence of seeded beetles of the same species resulted in an increase in beetle captures for both T. castaneum and T. confusum, but when traps were seeded with the opposite species, there was no increase in beetle captures for either species, and for T. castaneum overall captures in both seeded and unseeded traps was reduced. Overall, T. castaneum tended to have greater captures than T. confusum regardless of the treatment. When the two species were released together, this negated the increased response to seeded traps observed in the single-species treatments. These findings suggest the potential that the presence of beetles in a trap may be influencing the response of beetles in a nearby trap and that T. castaneum and T. confusum when they occur together may influence each other's response to traps.