Improving Performance of Al2O3/AlN/GaN MIS HEMTs via In Situ N2 Plasma Annealing
Open Access
- 23 May 2023
- journal article
- research article
- Published by MDPI AG in Micromachines
- Vol. 14 (6) , 1100
Abstract
A novel monocrystalline AlN interfacial layer formation method is proposed to improve the device performance of the fully recessed-gate Al2O3/AlN/GaN Metal-Insulator-Semiconductor High Electron Mobility Transistors (MIS-HEMTs), which is achieved by plasma-enhanced atomic layer deposition (PEALD) and in situ N2 plasma annealing (NPA). Compared with the traditional RTA method, the NPA process not only avoids the device damage caused by high temperatures but also obtains a high-quality AlN monocrystalline film that avoids natural oxidation by in situ growth. As a contrast with the conventional PELAD amorphous AlN, C-V results indicated a significantly lower interface density of states (Dit) in a MIS C-V characterization, which could be attributed to the polarization effect induced by the AlN crystal from the X-ray Diffraction (XRD) and Transmission Electron Microscope (TEM) characterizations. The proposed method could reduce the subthreshold swing, and the Al2O3/AlN/GaN MIS-HEMTs were significantly enhanced with ~38% lower on-resistance at Vg = 10 V. What is more, in situ NPA provides a more stable threshold voltage (Vth) after a long gate stress time, and ΔVth is inhibited by about 40 mV under Vg,stress = 10 V for 1000 s, showing great potential for improving Al2O3/AlN/GaN MIS-HEMT gate reliability.Keywords
This publication has 35 references indexed in Scilit:
- Surface nitridation for improved dielectric/III‐nitride interfaces in GaN MIS‐HEMTsPhysica Status Solidi (a), 2014
- Al2O3/AlN/GaN MOS-Channel-HEMTs With an AlN Interfacial LayerIEEE Electron Device Letters, 2014
- Gate Recessed Quasi-Normally OFF Al2O3/AlGaN/GaN MIS-HEMT With Low Threshold Voltage Hysteresis Using PEALD AlN Interfacial Passivation LayerIEEE Electron Device Letters, 2014
- AlN passivation by plasma-enhanced atomic layer deposition for GaN-based power switches and power amplifiersSemiconductor Science and Technology, 2013
- Impact of $\hbox{N}_{2}$ Plasma Power Discharge on AlGaN/GaN HEMT PerformanceIEEE Transactions on Electron Devices, 2011
- Enhancement-Mode GaN MIS-HEMTs With n-GaN/i-AlN/n-GaN Triple Cap Layer and High- $k$ Gate DielectricsIEEE Electron Device Letters, 2010
- Detection of Ga suboxides and their impact on III-V passivation and Fermi-level pinningApplied Physics Letters, 2009
- Model of interface states at III-V oxide interfacesApplied Physics Letters, 2009
- Effects of $\hbox{N}_{2}$ Plasma Pretreatment on the SiN Passivation of AlGaN/GaN HEMTIEEE Electron Device Letters, 2008
- N 2 – H 2 remote plasma nitridation for GaAs surface passivationApplied Physics Letters, 2002