D. L. Fletcher

Saponification of xanthophyll esters in various feed sources has been shown to improve pigmentation efficiency in broiler skin and egg yolks. Three trials were conducted to evaluate a rapid liquid chromatography procedure for estimating the relative degree of xanthophyll saponification using samples of yellow corn, corn gluten meal, alfalfa, and 6 commercially available marigold meal concentrates. In each trial, samples were extracted using a modification of the 1984 Association of Official Analytical Chemists hot saponification procedure with and without the addition of KOH. A comparison of the chromatography results was used to estimate percent saponification of the original sample by dividing the nonsaponified extraction values by the saponified extraction values. A comparison of the percent saponified xanthophylls for each product (mg/kg) was: yellow corn, 101; corn gluten meal, 78; alfalfa, 97.9; and marigold concentrates A through F, 99.8, 4.6, 99.0, 95.6, 96.8, and 6.6, respectively. These results indicate that a modification of the 1984 Association of Official Analytical Chemists procedure and liquid column chromatography can be used to quickly verify saponification and can be used to estimate the relative degree of saponification of an unknown xanthophyll source.

In recent years, demand for white meat products has resulted in excess supplies and depressed prices of leg meat in the United States. One approach to increasing the utilization of dark meat is to extract the pigments and fat to make the resulting product more acceptable for the production of further-processed meat products. To date, such technologies have been inefficient (low yields) or have resulted in products of limited use. Three replicate trials were conducted to determine the effects of extraction pH and precipitation pH on the wet and dry extract yields of boneless, skinless broiler leg meat. Broiler leg meat was chopped with added water and extracted by adjusting the pH to 8.0, 8.5, 9.0, 9.5, 10.0, 10.5, 11.0, 11.5, and 12.0 while mixing. After determination of extraction yields, each extraction was adjusted to pH 3.8, 4.0, 4.2, 4.4, 4.6, 4.8, 5.0, and 5.2 to determine the effect of precipitate pH on total wet and dry yields. Dry yield increased with extraction pH and precipitation pH. However, the greatest yields, over 70%, were at extraction pH values above 10.5, which have been associated with the production of potentially harmful by-products. Combinations of extraction pH values between 9 and 10.5 and precipitation pH values above 4.4 resulted in dry yields of approximately 65%. These results indicate that pH extraction and precipitation may result in economically viable yields. Further research is needed to determine the optimal conditions of yield, composition, and functionality.

The functional and physical properties of intact and ground meat were determined during 4 replicate trials on a total of 180 pale [lightness (L*) > 53] and normal (46 < L* < 53) boneless, skinless breast fillets collected from 2 commercial processing plants. At 24 h postmortem, L*, redness (a*), yellowness (b*), and pH were determined on each fillet. The left fillet from each breast was ground and used to determine cook loss (CL) and Allo-Kramer (AK) shear on meat patties as well as moisture uptake (MU) and CL on meat slurries before and after adjustment to the normal meat pH of 5.9. The right fillet from each breast was kept intact and used to determine expressible moisture (EM), CL, and AK shear on the intact meat. Compared with normal fillets, pale fillets exhibited significantly higher L* values, lower ultimate pH (5.67 vs. 5.94), higher AK (3.5 vs. 2.9 kg/g), higher EM, lower MU, and higher CL measured on the intact fillets, ground meat patties, and meat slurries. Adjustment of the pH of the pale meat slurries to normal meat pH (5.9) resulted in a higher MU (11.05 vs. 3.69%), indicating a partial restoration of protein functionality. These results indicate that wide differences in raw broiler breast meat color, mainly due to differences in the muscle pH, are related to important variations in the water-holding and binding capacities of the meat. The effect of low meat pH can be partially ameliorated in ground meat by pH adjustment.

Trisodium phosphate (TSP) has been reported to decrease the recovery of salmonellae from processed poultry carcasses. It has been suggested that the high pH and detergent-like properties of TSP solutions are responsible for the reduction in salmonellae recovery. This project was conducted to determine if controlling pH during salmonellae pre-enrichment alters the effect of TSP on salmonellae recovery. Carcasses were obtained from a commercial processing plant immediately after the final inside-outside carcass washer, prior to any other antimicrobial treatments, and before chilling. Carcasses were assigned to 1 of 4 treatment groups: (1) TSP and alkaline pre-enrichment, (2) TSP and neutral pre-enrichment, (3) non-TSP and alkaline pre-enrichment, 4) non-TSP and neutral pre-enrichment. Carcasses were placed into plastic bags with 500 mL of buffered peptone water (with or without pH adjustment) and shaken for 1 min. Preincubation pH of the rinsate was measured. Carcasses were incubated in the rinse at 37 degrees C for 24 h, and incidence of salmonellae was determined. The pH of the preincubation rinsate was 8.4 for the TSP alkaline pre-enrichment, 7.2 for the TSP neutral pre-enrichment, 8.6 for the non-TSP alkaline pre-enrichment, and 7.1 for the non-TSP neutral pre-enrichment. Salmonellae were detected from 40% of the TSP alkaline pre-enrichment carcasses, 44% of the TSP neutral pre-enrichment carcasses, 54% of the non-TSP alkaline pre-enrichment carcasses, and 38% of the non-TSP neutral pre-enrichment carcasses. Neither TSP treatment nor pre-enrichment pH adjustment significantly influenced carcass salmonellae detection.

Experiments were conducted to determine the effect of prechill trisodium phosphate (TSP) treatment on reducing salmonellae recovery from broiler carcasses immediately after chilling or following 7 d of storage. Carcasses were sampled for salmonellae using whole carcass enrichment for 24 h at 37 degrees C. In each of 7 trials, 40 carcasses were obtained from a commercial processing plant. Batches of 4 carcasses were subjected to a 5-s dip in 10% TSP (treatment) or not dipped (control). Two carcasses from each batch were sampled immediately after chilling (d 0) and 2 carcasses were sampled after 7 d of storage. For trials 1 and 2, TSP treatment and control groups were chilled in separate chill tanks for 45 min. For trials 3 through 7, carcasses were rinsed with water and individually bagged with ice and water before chilling. For trials 1 and 2, 85% (17/20) of control carcasses were salmonellae-positive on d 0 compared with 45% (9/ 20) of the TSP-treated carcasses; after 7 d, 75% (15/20) of control carcasses were positive compared with 35% (7/ 20) for the TSP-treated carcasses. For trials 3 through 7, 46% (23/50) of control carcasses were salmonellae-positive on d 0 compared with 26% (13/50) of the TSP-treated carcasses; after 7 d, 20% (10/50) of control carcasses were positive compared with 4% (2/50) of the TSP-treated carcasses. TSP treatment resulted in significantly higher pH values for rinses. Salmonella recovery was decreased by refrigerated storage and treatment with TSP before immersion chilling.

An experiment was conducted to compare the effectiveness levels of two methods in recovering Salmonella from the same carcass. One hundred fresh whole broiler chickens were purchased from retail ou...

Three independent trials were conducted to determine the effects of high frequency electrical stunning followed by decapitation on broiler breast meat rigor development and meat quality. All birds were stunned and half of the birds were killed using a conventional unilateral neck cut, half were killed by decapitation, and both groups were allowed to bleed for 90 s prior to scalding and picking. New York dressed carcasses were chilled in a static ice-water bath for 90 min and held at 2 degrees C prior to deboning. Breast fillets were removed from the carcasses at 2, 4, and 24 h postmortem. From the right breast fillet, R-values and pH were determined at time of deboning. The left fillet was wrapped in plastic and held for 24 h at 2 degrees C prior to determining lightness (L*), redness (a*), yellowness (b*), cook yield, and Allo-Kramer shear. Deboning time affected raw meat pH, R-value, cook loss, and shear value but had no effect on color. The breast meat from the decapitated birds had significantly higher pH values at 2 and 24 h postmortem than the conventionally killed birds. Other than for the effect on breast meat pH, decapitation had no effect on rigor development, R-value, meat color, or meat quality as measured by cooked-meat yield and Allo-Kramer shear.

Fresh whole broiler carcasses were purchased from grocery stores over a 20-week period. Carcasses were selected on the basis of their having intact packages and unique U.S. Department of Agricultur...

Poultry meat quality - Volume 58 Issue 2 - D.L. Fletcher