Idoia Codina-Torrella

This study explores innovative approaches for sustainable food preservation by incorporating Sichuan pepper extract into biodegradable gelatin and alginate films. In response to growing environmental and health concerns, these natural polymers offer alternatives to petroleum-based plastics and synthetic additives. The aim of this study was to compare films made from gelatin and alginate and containing Sichuan pepper extract (2.5 and 5%) and to evaluate their effectiveness in extending the shelf life of refrigerated beef patties. Scavenging activity and polyphenol content of the extract were evaluated by DPPH (4.70 µmol TE/mL), ABTS (4.03 µmol TE/mL), and Folin–Ciocalteu assays (2.35 mg GAE/mL). In addition, the physical characteristics of the films were also assessed. Film characterization showed that gelatin-based films had greater stiffness (water-based alginate film; 1156 MPa), which diminished with increased extract content (5% extract-based alginate film: 215.5 MPa), and surface homogeneity also declined with higher extract content. However, higher concentrations of the extract (5%) improved optical properties such as UV protection and opacity. Preservation tests performed on beef patties revealed that the films with the extract could significantly reduce lipid oxidation, with lower TBARS values observed in samples covered with these films. Nevertheless, no significant differences were detected between films with the extract. Moreover, samples without the extract were the most oxidized, proving that the film without the extract had no protective effect against oxidation. Overall, these findings underscore the potential of Sichuan pepper as a natural ingredient and highlight the promise of biodegradable films as an effective and eco-friendly strategy for meat product packaging.

The present study aims to evaluate the physicochemical and sensory characteristics of A2 yoghurts (made with A2A2 β-CN milk), in comparison with Control yoghurts (elaborated from conventional milk, a mixture of A1 and A2 β-CN milk). The pH, acidity, water-holding capacity, spontaneous syneresis, firmness and color of yoghurts were monitored during their cold storage (4 °C) for 35 days. Two independent sensory tests (with expert judges and consumers) were also performed. The A2 yoghurts showed only minor differences in some of their physicochemical and sensory characteristics compared to those made with conventional milk. At specific storage times, the A2 yoghurt exhibited higher levels of acidity, luminosity (L*) and firmness, compared to the Control. No differences were observed in the growth curves of the starter (Lactobacillus delbrueckii subsp. bulgaricus and Streptococcus salivarius subsp. thermophilus) during the yoghurt production, nor in the water-holding capacity or spontaneous syneresis of the two types of gels. Regarding the sensory evaluation of samples, the A2 yoghurts were described as firmer and more adherent (by the expert panel), and brighter and more homogeneous (by the consumers) than the Control. In all cases, both consumers and expert sensory panels showed a preference for the A2 yoghurts. Therefore, these results demonstrate the suitability of A2A2 β-CN milk for producing yoghurts with similar characteristics to those obtained with conventional milk.

Calcium alginate spheres with a volume of about 5 mL can be used for important purposes. Those that incorporate oolong tea give, in addition to the recreational aspect, the possibility of drinking small quantities of this tea, because oolong tea can be used as a compound with antioxidant properties. This incorporation can be achieved by reverse spherification (5 mL). Six types of spheres have been made, all of them with calcium alginate and the presence or absence of agar-agar and xanthan gum—XG—in two concentrations. The weight loss of the spheres, the release of bioactive compounds over time (a total of 48 h), the surface (internal and external) of the membranes, and the physical characteristics of these membranes have been analyzed. The data obtained indicate that the presence of XG prevents the formation of precipitates inside the spheres and slows down weight loss. It also provides opacity to the spheres. However, the incorporation of agar-agar does not have a significant influence on the different parameters analyzed. The release of catechins reaches a maximum of 80% of what could be achieved under ideal conditions, and it reaches 90% in the first 3 h. The incorporation of XG increases the shelf life of the spheres, slows down the release of chelate, and decreases weight loss over time, allowing for a new perspective on the spherification process.

Myrtus communis L. is a species of the Myrtaceae family that is found in the Mediterranean region, and it is traditionally recognized for its importance and different uses. The objective of this study was to determine the effect of M. communis L. leaf extract (MCLE), which was incorporated directly into alginate spheres and films, on preserving oil-in-water emulsions from oxidation. For this purpose, the solvent extraction (with ethanol at 40, 60, and 80%) of the antioxidant compounds was optimized (total phenolic compounds (TPCs) and total flavonoid content (TFC)) along with the scavenging activity. The best condition for the extraction corresponded with 60% ethanol (MCLE60), with a TPC of ~66.06 g GAE/L and a TFC of ~18.91 g QE/L, which was selected for use in the following assays. MCLE60 showed a considerable radical scavenging activity (24.85 mmol TE/L in FRAP, 28.75 mmol TE/L in DPPH, 30.61 mmol TE/L in ABTS, and 14.94 mmol TE/L in ORAC), which was probably due to its content in the phenolic compounds arbutin (122.08 mg/L), epicatechin (73.89 mg/L), sinapic acid (51.85 mg/L), and gallic acid (36.72 mg/L). The oil-in-water emulsions with the MCLE60 spheres showed the best oxidative stability (TBARS ~2.64 mg MDA/kg of emulsion, PV ~35.7 meq hydroperoxides/kg of emulsion) in comparison to the control. The film was also able to protect the emulsion from oxidation for more than a week at 30 °C (TBARS ~1.9 mg MDA/kg of emulsion). The alginate films with MCLE60 presented an important release of phenolic compounds in water and acetic food simulants, while in both ethanol simulants, the release of TPC remained more stable over time. Thus, this study highlights the potential uses of MCLE as a natural ingredient for emulsion oxidative preservation and the production of alginate delivery systems (spheres and films).

Vegetative cells of Listeria monocytogenes and Escherichia coli and spores of Bacillus subtilis and Aspergillus niger were inoculated in soy milk at an initial concentration of ≈5 log CFU/mL. Inoculated and control (non-inoculated) soy milk samples were submitted to three types of treatments using a tubular annular thin film short-wave ultraviolet (UV-C) reactor with 1 mm of layer thickness. Treatments applied depended on the flow rate and the number of entries to the reactor, with UV-C doses ranging from 20 to 160 J/mL. The number of entries into the reactor tube (NET) was established as the most determining parameter for the efficiency of the UV-C treatments. Conidiospores of A. niger were reported as the most resistant, followed by B. subtilis spores, while vegetative cells were the most sensible to UV-C, with Listeria monocytogenes being more sensible than Escherichia coli. Treatments of just 80 J/mL were needed to achieve a 5 log CFU/mL reduction of L. monocytogenes while 160 J/mL was necessary to achieve a similar reduction for A. niger spores.

The interest in natural sources with high antioxidant powder has recently increased in several sectors. Ionic gelation methods could be used to protect bioactive substances to control the kinetics and release of these ingredients to the food matrix. This study dealt with the evaluation of the antioxidant capacity and scavenging activity of extracts of Hibiscus Sabdariffa L. (HSL) (with 50% ethanol) encapsulated in calcium alginate spheres as a new source for preserving food against oxidative damage. Their antioxidant activity was measured in different o/w emulsions in which HSL spheres reduced the formation of hydroperoxides (~80%) and thiobarbituric-acid-reactive substance products (~20%). The scavenging activity of HSL extracts was measured in different food simulants (water, water acidified with 3% acetic acid, ethanol at 50%, and pure ethanol), and corresponded to 0.20–0.43, 0.31–0.62, and 11.13–23.82 mmol Trolox/mL extract for Trolox equivalent antioxidant capacity (TEAC), 2,2-diphenylpicrylhydrazyl (DPPH), and oxygen radical absorbance capacity (ORAC) assays, respectively. In general, the best antiradical activity was observed in the ethanolic and acidified mediums, in which the highest concentration of released polyphenols ranged from 0.068 to 0.079 mg GAE/mL. This work indicates the potential of alginate spheres for encapsulating antioxidant compounds as an innovative strategy for several industrial applications.

Tiger nut beverages are non-alcoholic products that are characterized by their pale color and soft flavor. Conventional heat treatments are widely used in the food industry, although heated products are often damaging to their overall quality. Ultra-high pressure homogenization UHPH) is an emerging technology that extends the shelf-life of foods while maintaining most of their fresh characteristics. The present work deals with the comparison of the effect of conventional thermal homogenization-pasteurization (H-P, 18 + 4 MPa at 65 °C, 80 °C for 15 s.) and UHPH (at 200 and 300 MPa, and inlet temperature of 40 °C), on the volatile composition of tiger nut beverage. Headspace-solid phase microextraction (HS-SPME) was used for detecting volatile compounds of beverages, which were then identified by gas chromatography-mass spectrometry (GC-MS). A total of 37 different volatile substances were identified in tiger nut beverages, which were primarily grouped into the aromatic hydrocarbons, alcohols, aldehydes and terpenes chemical families. Stabilizing treatments increased the total amount of volatile compounds (H-P > UHPH > R-P). H-P was the treatment that produced the most changes in the volatile composition of RP, while treatment at 200 MPa had a minor impact. At the end of their storage, these products were also characterized by the same chemical families. This study evidenced the UHPH technology as an alternative processing of tiger nut beverages production that minimally modifies their volatile composition.

The effect of ultra-high-pressure homogenization (UHPH) treatments at 300 MPa at inlet temperatures (T_i) between 45 and 75 °C on the microbiological, physical, and sensorial characteristics of fish broth was evaluated. Before the application of UHPH treatments, different fish broth formulations were tested, selecting the formula with the best organoleptic and nutritional characteristics and the lowest cost, containing 45% monkfish heads and rock fish in the same proportion. The microbiological shelf-life of fish broth during cold storage at 4 and 8 °C was extended by a minimum of 20 days by applying UHPH treatments at inlet temperatures (T_i) between 45 and 65 °C. Fish broth UHPH-treated at T_i = 75 °C was microbiologically sterile during storage at 4 °C, 8 °C, and room temperature. Fish broth UHPH-treated was physically stable, significantly reducing the particle size. Color showed higher luminosity and lower yellowness as the inlet temperature increased. In fish broth UHPH-treated at T_i = 75 °C, selected for its microbiological stability, no differences were observed in the nutritional composition, antioxidant activity, and sensorial perception compared to untreated fish broth. Hence, UHPH treatments showed to be an alternative to preserving fish broth with an improved microbiological shelf-life and good sensorial characteristics.

The present study aims to identify and quantify the phenolic compounds of Azadirachta indica leaf extract using HPLC-MS and to evaluate the antioxidant, antibacterial (against different Gram-positive and negative bacteria) and in vitro anti-proliferative activities of this extract (against breast, human liver and cervix adenocarcinoma-derived cells). The application of this extract as a natural antioxidant for food preservation was also tested on oil-in-water food emulsions for the first time in the present work in order to determine the use of Azadirachta indica leaves as a natural additive to preserve the food against lipid oxidation and rancidity. The results obtained revealed that 50%-aqueous ethanol leaf extract showed the best extraction yield (25.14%), which was characterized by a high content in phenolic compounds and strong antioxidant activity. Moreover, this leaf extract inhibited the growth of the bacterial strains tested (Staphylococcus aureus, Escherichia coli, Salmonella paratyphi and Micrococcus luteus) and showed better anti-proliferative activity against breast and cervix adenocarcinoma-derived cells than human liver cancer cells after 48 h of treatment. Additionally, Azadirachta indica leaf extract showed almost similar effects as gallic acid solutions (0.25% and 0.5%) in preserving the oxidation of oil-in-water food emulsions and prevented the formation of secondary oxidation products (malondialdehyde) as well. The results obtained suggested that extracts of Azadirachta indica leaves are a potential source of antioxidant and antibacterial compounds and pointed to the potential of these natural extracts as therapeutic agents.